Components Inside Front Passenger Compartment Component Location Overview, Climatic through 27 May 2011
Components Inside Front Passenger Compartment Component Location Overview, Climatic through 27 May 2011
• Disconnect the battery before removing components marked with a **.
• A data plate indicates the refrigerant used and capacity.
1 Dash panel **
2 Center Outlet Temperature Sensor (G191)
• Removing and installing, refer to => [ Center Vent Temperature Sensor G191 ] Center Vent Temperature Sensor G191.
3 Center vents
• Removing and installing, refer to => [ Front Center Vents ] Front Center Vents.
4 Right Side Vent
5 Controls for Heating and A/C System, Climatic
• Passat from MY 06
• With fresh air/recirculating door switch (E159)
• With rear window defogger switch (E230)
• With fresh air blower switch (E9)
• On vehicles with heated seals also with heated driver seat adjuster (E94) and heated front passenger seat adjuster (E95)
• With A/C control module (J301)
• Removing and installing, refer to => [ Display and Control Unit, Climatic ] Display and Control Unit, Climatic.
6 Controls for Heating and A/C System, Climatic
• Passat CC from MY 09
• With fresh air/recirculating door switch (E159)
• With rear window defogger switch (E230)
• with fresh air blower switch (E9)
• On vehicles with heated seals also with heated driver seat adjuster (E94) and heated front passenger seat adjuster (E95)
• Removing and installing, refer to => [ Display and Control Unit, Climatic ] Display and Control Unit, Climatic.
7 Fresh/Recirculated Air Door Motor (V154)
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Fresh/Recirculated Air Door Motor V154 ] Fresh/Recirculated Air Door Motor V154.
• Replacing: initiate the basic setting using the Vehicle Diagnostic Tester. Refer to => [ Climatronic Components, Checking and Adjusting ] Climatronic Components, Checking and Adjusting.
8 Air Distribution Door Motor (V428) with Air Distribution Door Motor Position Sensor (G645)
• Passat CC from MY 09
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Air Distribution Door Motor V428, Passat CC from MY 09 and CC from MY 10 ] Air Distribution Door Motor V428, Passat CC from MY 09 and CC from MY 10.
• Replacing: initiate the basic setting using the Vehicle Diagnostic Tester. Refer to => [ Climatronic Components, Checking and Adjusting ] Climatronic Components, Checking and Adjusting.
9 Right Footwell Vent
• Removing and installing, refer to => [ Front Passenger Footwell Right Vent ] Front Passenger Footwell Right Vent.
10 Fresh Air Blower (V2)
• Removing and installing, refer to => [ Fresh Air Blower V2 ] Service and Repair.
11 Fresh Air Blower Series Resistor With Fuse (N24)
• Removing and installing, refer to => [ Fresh Air Blower Series Resistor with Fuse N24 ] Service and Repair.
12 Evaporator Vent Temperature Sensor (G263)
• Removing and installing, refer to => [ Evaporator Vent Temperature Sensor G263 or Evaporator Temperature Sensor G308 ] Evaporator Vent Temperature Sensor G263 or Evaporator Temperature Sensor G308.
13 Heating Unit Partition
• Removing, refer to => [ Removing Heater Partition ] Heater Component Location Overview
14 Dust and Pollen Filter
• Removing and installing, refer to => [ Dust and Pollen Filter ] Dust and Pollen Filter.
15 Cap
• Only in vehicles without air guide to vent installed in center console at rear.
16 Connection
• For air duct, rear vent
• It is necessary to first remove the center console in order to remove the connection.
17 Rear Vent Air Duct
• Removing and installing, refer to => [ Rear Vent Air Duct ] Rear Vent Air Duct.
18 Rear Vent
• Removing and installing, refer to => [ Rear Vent ] Rear Vent.
19 Right Footwell Rear Channel
• Removing and installing, refer to => [ Rear Channel, Footwell ] Rear Channel, Footwell.
20 Left Footwell Rear Channel
• Removing and installing, refer to => [ Rear Channel, Footwell ] Rear Channel, Footwell.
21 Screw
• Quantity: 8
22 Adapter for Controls
• Passat from MY 06
23 Auxiliary Heater Heating Element (Z35)
• Not applicable to the US or Canada
24 Left Footwell Vent
• Removing and installing, refer to => [ Driver Footwell Vent ] Driver Footwell Vent.
25 Heater Core
• Removing and installing, refer to => [ Heater Core ] Heater Core.
26 Footwell Outlet Temperature Sensor (G192)
• Removing and installing, refer to => [ Footwell Vent Temperature Sensor G192 ] Footwell Vent Temperature Sensor G192.
27 Temperature Regulator Door Motor (V68) with Temperature Regulator Door Motor Position Sensor (G92)
• Checking: use the Vehicle Diagnostic Tester
• Removing and installing, refer to => [ Temperature Regulator Door Motor V68 ] Temperature Regulator Door Motor V68.
• Replacing: initiate the basic setting using the Vehicle Diagnostic Tester. Refer to => [ Climatronic Components, Checking and Adjusting ] Climatronic Components, Checking and Adjusting.
28 Flexible Shaft
• Removing and installing, refer to => [ Flexible Air Distribution Shaft ] Flexible Air Distribution Shaft.
• Passat from MY 06
29 Heating and A/C unit
• Removing and installing, refer to => [ Heater and A/C Unit, through 30 October 2008 ] Heater and A/C Unit, through 30 October 2008.
• Disassembling and assembling, refer to => [ Heater and A/C, Climatic ] Heater and A/C, Climatic.