Headliner, Lowering and Installing, Passat CC from MY 2009 and CC from MY 2010

Headliner, Lowering and Installing, Passat CC from MY 2009 and CC from MY 2010

• When working on the side curtain airbag, the roof insulation/reinforcement or roof antenna, remove the headliner. It is not necessary to do this when removing the windshield.

Removing

- If equipped, open the Panorama sunroof.

- Switch off the ignition.

- Remove the front interior and reading lights.

- Remove the roof grab handles on vehicles without Panorama sunroof => [ Roof Grab Handles ] Service and Repair

- Remove upper trim on A-pillars => [ A-Pillar Upper Trim for Passat CC from 2009 and CC from 2010 ] A-Pillar Upper Trim for Passat CC from 2009 and CC from 2010

- Remove the upper B-pillar trim from the brackets => [ Upper B-Pillar trim, Tightening and Loosening from Mount for Passat CC from 2009 and CC from 2010 ] Upper B-Pillar trim, Tightening and Loosening from Mount for Passat CC from 2009 and CC from 2010.

- Remove visors => [ Basic Sun Visors, Passat from MY 2006 and Passat Wagon from MY 2006 ] Basic Sun Visors, Passat from MY 2006 and Passat Wagon from MY 2006.

- Remove the C-pillar trim:

• Vehicles not equipped with a sun shade => [ C-Pillar Trim, Vehicles without Sun Shade, Passat CC from MY 2009 and CC from MY 2010 ] C-Pillar Trim, Vehicles without Sun Shade, Passat CC from MY 2009 and CC from MY 2010

• Vehicles equipped with a sun shade => [ C-Pillar Trim, Vehicles with Sun Shade, Passat CC from MY 2009 and CC from MY 2010 ] C-Pillar Trim, Vehicles with Sun Shade, Passat CC from MY 2009 and CC from MY 2010

- Using the trim removal wedge (3409) remove the caps from the mirror - arrows -.






- Disconnect the connector - 1 - and remove the screws - 2 - (1.6 Nm).






- On vehicles equipped with a Panorama sunroof, remove the clamping profile - 1 - from the mounting clamps - 2 - - arrow -using the release tool (T10236) and the trim removal wedge (3409).

• In total, the clamping profile is attached by 20 clips.






- Loosen the headliner around the C-pillars toward the inside and out of the catches - arrow -.






- Pull the headliner - 1 - downward and out of the remaining retainers.






Installing

- Install in reverse order of removal.

• The installation of the headliner is made much easier by replacing clips "part number: 1K0 867 633" below the roof grab handle. Therefore, replacing the old clips is recommended.