Installation
SEAT: FRONT POWER SEAT MOTOR ASSEMBLY: INSTALLATION
CAUTION:
Wear protective gloves. Sharp areas on the parts may injure your hands.
HINT
* Use the same procedure for the RH and LH sides.
* The procedure listed below is for the LH side.
* A bolt without a torque specification is shown in the standard bolt chart Standard Bolt - Specified Torque For Standard Bolts.
1. INSTALL FRONT SEAT WIRE LH
(a) Attach the wire harness clamps and connect the connectors to install the seat wire.
(b) Install the bolt.
Torque : 16 Nm (163 kgf-cm, 12 ft-lbf)
2. INSTALL SEAT POSITION AIRBAG SENSOR Installation
3. INSTALL SEAT CLIMATE CONTROL BLOWER LH (w/ Climate Control Seat System) Reassembly
4. INSTALL SEAT CLIMATE CONTROL ECU (w/ Climate Control Seat System) Reassembly
5. INSTALL FRONT NO. 1 SEAT TRAVEL LINK Reassembly
6. INSTALL FRONT NO. 2 SEAT TRAVEL LINK Reassembly
7. INSTALL NO. 1 SEAT CUSHION PLATE Reassembly
8. INSTALL FRONT SEAT CUSHION SPRING Reassembly
9. INSTALL FRONT SEAT CUSHION SHIELD LOWER Reassembly
10. INSTALL RECLINING ADJUSTER INSIDE COVER RH Reassembly
11. INSTALL RECLINING ADJUSTER INSIDE COVER LH Reassembly
12. INSTALL FRONT SEATBACK FRAME ASSEMBLY LH Reassembly
13. INSTALL FRONT SEAT HEADREST ADJUSTER SUB-ASSEMBLY LH
(a) Attach the 2 claws.
(b) Install the headrest adjuster with the 2 bolts.
Torque : 5.5 Nm (56 kgf-cm, 49 in-lbf)
(c) Connect the connector and attach the 2 wire harness clamps.
(d) Attach the 2 hooks.
(e) Install the dynamic damper frame with the 2 bolts.
Torque : 5.5 Nm (56 kgf-cm, 49 in-lbf)
14. INSTALL FRONT SEAT HEADREST ADJUSTER SUB-ASSEMBLY RH (w/ Retractable Headrest)
(a) Attach the 2 claws to install the motor.
(b) Attach the 2 claws to install the headrest adjuster.
(c) Install the 4 bolts and 2 screws.
Torque : 21 Nm (214 kgf-cm, 15 ft-lbf) for bolt
(d) Connect the connector.
15. INSTALL ACTIVE HEADREST INFLATOR (w/ Active Headrest) Installation
16. INSTALL SEATBACK COVER WITH PAD Reassembly
17. INSTALL POWER SEAT SWITCH ASSEMBLY RH (except 5-Passenger with Ottoman) Reassembly
18. INSTALL FRONT SEAT HEADREST SUPPORT LH Reassembly
19. INSTALL FRONT SEAT HEADREST ASSEMBLY LH Reassembly
20. INSTALL FRONT SEAT CUSHION ASSEMBLY LH Reassembly
21. INSTALL FRONT SEATBACK BOARD SUB-ASSEMBLY LH Reassembly
22. INSTALL FRONT SEAT CUSHION SHIELD INNER LH Reassembly
23. INSTALL FRONT SEAT INNER BELT ASSEMBLY LH Installation
24. INSTALL FRONT NO. 1 SEAT CUSHION SHIELD LH Reassembly
25. INSTALL FRONT SEAT CUSHION SHIELD LH Reassembly
26. INSTALL FRONT SEAT ASSEMBLY LH
(a) Install the front seat assembly Installation.
27. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL
NOTICE:
When disconnecting the cable, some systems need to be initialized after the cable is reconnected Repair Instruction - Initialization.
28. CHECK SRS WARNING LIGHT
(a) Check the SRS warning light Diagnosis System.
29. CHECK FRONT SEAT ASSEMBLY
(a) Check the power seat operation Operation Check.
(b) w/ Climate Control Seat System:
Check the climate control seat system Operation Check.