Installation
PARKING BRAKE: PARKING BRAKE LEVER: INSTALLATION
1. INSTALL PARKING BRAKE LEVER SUB-ASSEMBLY
(a) Pass the No. 1 parking brake cable assembly through the parking brake lever and hold the cable with the clip.
(b) Pass the parking brake cable through the lever guide. Temporarily tighten the No. 1 wire adjusting nut and lock nut.
HINT
Fully tighten the No. 1 wire adjusting nut and lock nut when adjusting the parking brake lever free play.
(c) Fully bend the parking brake lever claw.
(d) Install the No. 1 parking brake cable assembly through the floor hole.
(e) Install the No. 1 parking brake cable assembly with the 2 bolts.
Torque : 8.0 Nm (82 kgf-cm, 71 in-lbf)
(f) Install the parking brake lever with the 2 bolts.
Torque : 39 Nm (400 kgf-cm, 29 ft-lbf)
(g) Connect the parking brake switch connector.
(h) Install the parking brake equalizer to the No. 1 parking brake cable assembly.
(i) Slide the rubber boot back as shown in the illustration.
(j) Connect the 2 No. 2 parking brake cable assemblies to the parking brake equalizer.
(k) Install the parking brake No. 2 and No. 3 cable assemblies with the 2 bolts.
Torque : 6.0 Nm (61 kgf-cm, 53 in-lbf)
(l) Using needle-nose pliers, install the parking brake return with damper spring.
2. INSTALL PROPELLER SHAFT WITH CENTER BEARING ASSEMBLY
Installation
3. INSTALL FRONT FLOOR REAR UPPER SUB PANEL SUB-ASSEMBLY
(a) Install the front floor rear upper sub panel with the 4 bolts.
Torque : 18 Nm (184 kgf-cm, 13 ft-lbf)
(b) Engage the 6 clamps.
4. INSTALL CENTER AIRBAG SENSOR ASSEMBLY Installation
5. INSTALL NO. 2 CONSOLE BOX DUCT Installation
6. INSTALL CONSOLE BOX Installation
7. INSTALL CONSOLE BOX REGISTER ASSEMBLY (w/ Ashtray) Installation
8. INSTALL CONSOLE BOX REGISTER ASSEMBLY (w/o Ashtray) Installation
9. INSTALL FRONT ASH RECEPTACLE BOX SUB-ASSEMBLY (w/ Ashtray) Installation
10. INSTALL INSTRUMENT PANEL BOX ASSEMBLY (w/o Ashtray) Installation
11. INSTALL FRONT CONSOLE PANEL SUB-ASSEMBLY Installation
12. INSTALL REAR CONSOLE PANEL SUB-ASSEMBLY Installation
13. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY
14. INSTALL FRONT DOOR OPENING TRIM COVER LH Installation
15. INSTALL CENTER PILLAR GARNISH LOWER LH Installation
16. INSTALL REAR DOOR SCUFF PLATE LH Installation
17. INSTALL FRONT DOOR SCUFF PLATE LH Installation
18. INSTALL FRONT SEAT OUTER BELT ASSEMBLY
Installation
19. INSTALL REAR SEAT CUSHION ASSEMBLY Installation
20. INSTALL FRONT SEAT ASSEMBLY (for Standard Type Power Seat)
Installation
21. INSTALL FRONT SEAT ASSEMBLY (for Sports Type Power Seat)
Installation
22. INSTALL FRONT SEAT ASSEMBLY (for Manual Seat)
Installation
23. INSPECT PARKING BRAKE LEVER TRAVEL Adjustments
24. ADJUST PARKING BRAKE LEVER TRAVEL Adjustments
25. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL
26. INSPECT SRS WARNING LIGHT
Diagnosis System