Removal
AIR CONDITIONING: AIR INLET CONTROL SERVO MOTOR: REMOVAL
CAUTION:
Some of these service operations affect the SRS airbag system. Read the precautionary notices concerning the SRS airbag system before servicing Service Precautions.
1. ALIGN FRONT WHEELS FACING STRAIGHT AHEAD
2. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL
CAUTION:
Wait for at least 90 seconds after disconnecting the cable to prevent the airbag from working.
3. RECOVER REFRIGERANT FROM REFRIGERATION SYSTEM Service and Repair
4. DISCONNECT SUCTION PIPE SUB-ASSEMBLY Removal
5. DISCONNECT AIR CONDITIONING TUBE AND ACCESSORY ASSEMBLY Removal
6. DISCONNECT HEATER OUTLET WATER HOSE Removal
7. DISCONNECT HEATER INLET WATER HOSE Removal
8. BOLTS, SCREWS AND NUTS TABLE Removal
9. REMOVE FRONT DOOR OPENING TRIM WEATHERSTRIP RH Removal
10. REMOVE FRONT DOOR OPENING TRIM WEATHERSTRIP LH Removal
11. REMOVE FRONT PILLAR GARNISH RH Removal
12. REMOVE FRONT PILLAR GARNISH LH Removal
13. REMOVE INSTRUMENT CLUSTER FINISH CENTER PANEL SUB-ASSEMBLY Removal
14. DISCONNECT INSTRUMENT CLUSTER FINISH LOWER PANEL Removal
15. REMOVE INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY Removal
16. REMOVE COMBINATION METER ASSEMBLY Removal
17. REMOVE GLOVE COMPARTMENT DOOR ASSEMBLY Removal
18. REMOVE UPPER INSTRUMENT PANEL SUB-ASSEMBLY Removal
19. REMOVE FRONT DOOR SCUFF PLATE RH Removal
20. REMOVE FRONT DOOR SCUFF PLATE LH Removal
21. REMOVE COWL SIDE TRIM BOARD RH Removal
22. REMOVE COWL SIDE TRIM BOARD LH Removal
23. REMOVE SHIFT LEVER KNOB SUB-ASSEMBLY (for Manual Transaxle) Removal
24. REMOVE INSTRUMENT CLUSTER FINISH CENTER LOWER PANEL Removal
25. REMOVE FRONT NO. 2 CONSOLE BOX INSERT Removal
26. REMOVE FRONT NO. 1 CONSOLE BOX INSERT Removal
27. REMOVE INSTRUMENT PANEL FINISH LOWER PANEL Removal
28. DISCONNECT TRANSMISSION CONTROL CABLE ASSEMBLY (for Manual Transaxle) Removal
29. REMOVE SHIFT LEVER ASSEMBLY (for Manual Transaxle) Removal
30. DISCONNECT TRANSMISSION CONTROL CABLE ASSEMBLY (for Automatic Transaxle) Removal
31. REMOVE SHIFT LEVER ASSEMBLY (for Automatic Transaxle) Removal
32. SEPARATE AIR CONDITIONING PANEL ASSEMBLY Removal
33. DISCONNECT NO. 2 HEATER CONTROL CABLE SUB-ASSEMBLY Removal
34. DISCONNECT AIR MIX DAMPER CONTROL CABLE SUB-ASSEMBLY Removal
35. REMOVE NO. 1 SWITCH HOLE BASE Removal
36. REMOVE INSTRUMENT PANEL FINISH LOWER PANEL SUB-ASSEMBLY Removal
37. REMOVE INSTRUMENT PANEL SUB REINFORCEMENT Removal
38. REMOVE RADIO BRACKET Removal
39. REMOVE NO. 1 INSTRUMENT CLUSTER FINISH PANEL SEAL Removal
40. SEPARATE HOOD LOCK CONTROL LEVER SUB-ASSEMBLY Removal
41. SEPARATE ANTENNA CORD SUB-ASSEMBLY Removal
42. REMOVE LOWER INSTRUMENT PANEL SUB-ASSEMBLY Removal
43. REMOVE STEERING PAD Removal
44. REMOVE STEERING WHEEL ASSEMBLY Removal
45. REMOVE STEERING COLUMN COVER Removal
46. REMOVE TURN SIGNAL SWITCH ASSEMBLY WITH SPIRAL CABLE SUB-ASSEMBLY Removal
47. REMOVE COLUMN HOLE COVER SILENCER SHEET Removal
48. SEPARATE NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY Removal
49. REMOVE STEERING COLUMN ASSEMBLY Removal
50. REMOVE REAR NO. 3 AIR DUCT Removal
51. REMOVE REAR NO. 1 AIR DUCT Removal
52. REMOVE LOWER DEFROSTER NOZZLE ASSEMBLY Removal
53. REMOVE CENTER INSTRUMENT PANEL TO COWL BRACE Removal
54. REMOVE NO. 1 AIR DUCT SUB-ASSEMBLY Removal
55. SEPARATE RELAY BLOCK ASSEMBLY Removal
56. REMOVE INSTRUMENT PANEL BRACE SUB-ASSEMBLY Removal
57. REMOVE REAR NO. 2 AIR DUCT Removal
58. REMOVE POWER STEERING ECU ASSEMBLY Removal
59. DISCONNECT DRAIN COOLER HOSE Removal
60. SEPARATE INSTRUMENT PANEL WIRE Removal
61. REMOVE INSTRUMENT PANEL REINFORCEMENT ASSEMBLY (for Manual Transaxle) Removal
62. REMOVE INSTRUMENT PANEL REINFORCEMENT ASSEMBLY (for Automatic Transaxle) Removal
63. REMOVE AIR CONDITIONING UNIT Removal
64. REMOVE NO. 2 AIR DUCT SUB-ASSEMBLY Removal
65. REMOVE BLOWER ASSEMBLY Removal
66. REMOVE AIR INLET CONTROL SERVO MOTOR
(a) Remove the 2 screws and the air inlet servo motor.