Installation

PARKING BRAKE: PARKING BRAKE PEDAL: INSTALLATION

1. INSTALL PARKING BRAKE CONTROL PEDAL ASSEMBLY

(a) Install the parking brake control pedal assembly to the body, and temporarily tighten the 3 nuts.





(b) Fully tighten the 3 nuts in the order shown in the illustration.

Torque : 13 Nm (133 kgf-cm, 10 ft-lbf)

(c) Connect the parking brake switch connector.

(d) Connect the instrument panel junction block assembly with the 2 nuts.





(e) Install the No. 1 parking brake cable assembly to the body with the 3 nuts and 2 bolts.

Nut - Torque : 6.0 Nm (61 kgf-cm, 53 in-lbf)

Bolt - Torque : 8.0 Nm (82 kgf-cm, 71 in-lbf)





2. INSTALL PARKING BRAKE EQUALIZER

(a) Install the parking brake equalizer to the No. 1 parking brake cable assembly in the order shown in the illustration.





(b) Slide the rubber boot back as shown in the illustration.





(c) Connect the No. 2 parking brake cable assembly and No. 3 parking brake cable assembly to the parking brake equalizer.





(d) Install the No. 2 parking brake cable assembly and No. 3 parking brake cable assembly to the body with the 2 bolts.

Torque : 6.0 Nm (61 kgf-cm, 53 in-lbf)

3. INSTALL PARKING BRAKE RETURN WITH DAMPER SPRING

(a) Install the parking brake return with damper spring.





4. INSTALL PROPELLER SHAFT WITH CENTER BEARING ASSEMBLY

Installation

5. INSTALL FRONT UPPER FLOOR REAR SUB PANEL

(a) Install the front upper floor rear sub panel to the body with the 4 bolts.





Torque : 18 Nm (184 kgf-cm, 13 ft-lbf)

(b) Engage the 8 clamps.

6. INSTALL CENTER AIRBAG SENSOR ASSEMBLY Installation

7. INSTALL NO. 2 REAR AIR DUCT

8. INSTALL REAR AIR DUCT GUIDE LH

9. INSTALL FRONT FLOOR SILENCER PAD LH

10. INSTALL NO. 3 DASH PANEL INSULATOR PAD

(a) Install the No. 3 dash panel insulator pad with the clip.

11. INSTALL FRONT FLOOR FOOTREST LH

(a) Engage the 2 clips and install the front floor footrest LH.

12. INSTALL LOWER CENTER PILLAR GARNISH LH Installation

13. INSTALL FRONT SEAT OUTER BELT ASSEMBLY LH Installation

14. INSTALL LAP BELT OUTER ANCHOR COVER LH Installation

15. INSTALL REAR DOOR SCUFF PLATE LH Installation

16. INSTALL DRIVER SIDE KNEE AIRBAG ASSEMBLY

Installation

17. INSTALL NO. 2 CONSOLE BOX DUCT Installation

18. INSTALL CONSOLE BOX

Installation

19. INSTALL FRONT SEAT ASSEMBLY LH

Installation

20. INSTALL REAR SEAT CUSHION ASSEMBLY Installation

21. INSPECT FRONT SEAT ASSEMBLY Installation

22. ADJUST PARKING BRAKE SHOE CLEARANCE AND PARKING BRAKE PEDAL TRAVEL Adjustments

23. INSPECT BRAKE WARNING LIGHT Adjustments

24. INSPECT SRS WARNING LIGHT

Diagnosis System