Installation

PARKING BRAKE: PARKING BRAKE LEVER: INSTALLATION

1. INSTALL PARKING BRAKE LEVER SUB-ASSEMBLY

(a) Pass the No. 1 parking brake cable assembly through the parking brake lever and hold the cable with the clip.





(b) Pass the parking brake cable through the lever guide. Temporarily tighten the No. 1 wire adjusting nut and lock nut.

HINT
Fully tighten the No. 1 wire adjusting nut and lock nut when adjusting the parking brake lever free play.

(c) Fully bend the parking brake lever claw.

(d) Install the No. 1 parking brake cable assembly through the floor hole.





(e) Install the No. 1 parking brake cable assembly with the 2 bolts.

Torque : 8.0 Nm (82 kgf-cm, 71 in-lbf)

(f) Install the parking brake lever with the 2 bolts.





Torque : 39 Nm (400 kgf-cm, 29 ft-lbf)

(g) Connect the parking brake switch connector.





(h) Install the parking brake equalizer to the No. 1 parking brake cable assembly.





(i) Slide the rubber boot back as shown in the illustration.





(j) Connect the 2 No. 2 parking brake cable assemblies to the parking brake equalizer.





(k) Install the parking brake No. 2 and No. 3 cable assemblies with the 2 bolts.

Torque : 6.0 Nm (61 kgf-cm, 53 in-lbf)

(l) Using needle-nose pliers, install the parking brake return with damper spring.





2. INSTALL PROPELLER SHAFT WITH CENTER BEARING ASSEMBLY Installation

3. INSPECT AND ADJUST NO. 2 AND NO. 3 JOINT ANGLE Installation

4. INSTALL OUTSIDE AIR GUIDE PLATE Installation

5. INSTALL NO. 1 FRONT FLOOR HEAT INSULATOR Installation

6. INSTALL FRONT EXHAUST PIPE ASSEMBLY Installation

7. INSTALL OXYGEN SENSOR Installation

8. INSTALL FRONT CENTER FLOOR BRACE Installation

9. INSTALL NO. 1 REAR FLOOR PANEL BRACE Installation

10. INSTALL FRONT FLOOR REAR UPPER SUB PANEL SUB-ASSEMBLY

(a) Install the front floor rear upper sub panel with the 4 bolts.





Torque : 18 Nm (184 kgf-cm, 13 ft-lbf)

(b) Engage the 6 clamps.

11. INSTALL CENTER AIRBAG SENSOR ASSEMBLY Installation

12. INSTALL CONSOLE BOX Installation

13. INSTALL CONSOLE BOX REGISTER ASSEMBLY Installation

14. INSTALL FRONT ASH RECEPTACLE SUB-ASSEMBLY Installation

15. INSTALL FRONT CONSOLE PANEL SUB-ASSEMBLY Installation

16. INSTALL REAR CONSOLE PANEL SUB-ASSEMBLY Installation

17. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY

18. INSTALL FRONT DOOR OPENING TRIM COVER LH Installation

19. INSTALL CENTER PILLAR GARNISH LOWER LH Installation

20. INSTALL REAR DOOR SCUFF PLATE LH Installation

21. INSTALL FRONT DOOR SCUFF PLATE LH Installation

22. INSTALL FRONT SEAT OUTER BELT ASSEMBLY

HINT
Installation.

23. INSTALL REAR SEAT CUSHION ASSEMBLY Installation

24. INSTALL FRONT SEAT ASSEMBLY (for Standard Type Power Seat)

HINT
Installation

25. INSTALL FRONT SEAT ASSEMBLY (for Sports Type Power Seat)

HINT
Installation

26. INSTALL FRONT SEAT ASSEMBLY (for Manual Seat)

HINT
Installation

27. INSPECT PARKING BRAKE LEVER TRAVEL Adjustments

28. ADJUST PARKING BRAKE LEVER TRAVEL Adjustments

29. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

30. INSPECT SRS WARNING LIGHT

HINT
Diagnosis System.