Installation
SUPPLEMENTAL RESTRAINT SYSTEM: CURTAIN SHIELD AIRBAG ASSEMBLY:
INSTALLATION
1. INSTALL CURTAIN SHIELD AIRBAG ASSEMBLY
(a) Check that the engine switch is off.
(b) Check that the battery negative (-) cable is disconnected.
CAUTION: Wait for 90 seconds after disconnecting the cable to prevent airbag deployment.
(c) Install 4 new clips and 4 new spacers to the curtain shield air bag assembly as shown in the illustration.
NOTICE :
- Do not push in the pin.
- Make sure that the clips are installed in the correct direction.
- Make sure that the spacers are installed properly, in the correct direction, and that they are not damaged.
(d) Install the curtain shield airbag assembly with 5 new bolts.
Torque: 11 Nm (112 kgf-cm, 8 ft-lbf)
NOTE: Do not twist the curtain shield airbag assembly when installing it.
(e) Install the 4 clips with the curtain shield airbag assembly to the body panel as shown in the illustration.
NOTE: Make sure that the pins of the clips are pushed in firmly.
(f) Mark the clips.
HINT: Mark the clips to make sure that they are not reused.
(g) Connect the curtain shield airbag connector.
NOTE: When handling the airbag connector, take care not to damage the airbag wire harness.
2. INSTALL ROOF HEADLINING ASSEMBLY (for Standard) Installation
3. INSTALL ROOF HEADLINING ASSEMBLY (for Glass Roof) Installation
4. INSTALL ASSIST GRIP SUB-ASSEMBLY Installation
5. INSTALL SPOT LIGHT ASSEMBLY (for Standard) Installation
6. INSTALL SPOT LIGHT ASSEMBLY (for Glass Roof) Installation
7. INSTALL COAT HOOK Installation
8. INSTALL VISOR HOLDER Installation
9. INSTALL VISOR ASSEMBLY LH Installation
10. INSTALL VISOR ASSEMBLY RH Installation
11. INSTALL VISOR BRACKET COVER Installation
12. INSTALL ROOF CONSOLE BOX ASSEMBLY Installation
13. INSTALL RAIN SENSOR COVER Installation
14. INSTALL INNER REAR VIEW MIRROR STAY HOLDER COVER Installation
15. CONNECT STEREO COMPONENT AMPLIFIER ASSEMBLY CONNECTOR (w/ DVD Player) Installation
16. INSTALL LUGGAGE COMPARTMENT INNER TRIM COVER RH (w/ DVD Player) Reassembly
17. INSTALL REAR FLOOR FINISH PLATE (w/ DVD Player) Reassembly
18. INSTALL NO. 1 LUGGAGE COMPARTMENT TRIM HOOK (w/ DVD Player) Reassembly
19. INSTALL LUGGAGE HOLD BELT STRIKER ASSEMBLY (w/ DVD Player) Reassembly
20. INSTALL SPARE WHEEL COVER TRAY (w/ DVD Player)
21. INSTALL LUGGAGE COMPARTMENT FLOOR MAT (w/ DVD Player)
22. INSTALL FLOOR CARPET BRACKET LH Installation
23. INSTALL FLOOR CARPET BRACKET RH Installation
24. INSTALL SHIFT LEVER ASSEMBLY Installation
25. CONNECT TRANSMISSION CONTROL CABLE ASSEMBLY Installation
26. INSTALL NO. 2 CONSOLE BOX DUCT Installation
27. INSTALL NO. 3 CONSOLE BOX DUCT Installation
28. INSTALL REAR CONSOLE BOX ASSEMBLY Installation
29. INSTALL CONSOLE REAR END PANEL SUB-ASSEMBLY Installation
30. INSTALL CONSOLE BOX CARPET Installation
31. INSTALL CONSOLE BOX POCKET Installation
32. INSTALL HEATER SEAT SWITCH CONSOLE BASE (w/o Seat Heater System) Installation
33. INSTALL HEATER SEAT SWITCH CONSOLE BASE (w/ Seat Heater System) Installation
34. INSTALL UPPER CONSOLE PANEL ASSEMBLY WITH FRONT ASH RECEPTACLE Installation
35. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY Installation
36. INSTALL INSTRUMENT PANEL FINISH PANEL END LH Installation
37. INSTALL INSTRUMENT PANEL FINISH PANEL END RH Installation
38. INSTALL ROOF SIDE INNER GARNISH ASSEMBLY LH Installation
39. INSTALL REAR SEAT SIDE GARNISH LH (w/o Rear Seat Side Airbag) Installation
40. INSTALL REAR SEAT SIDE AIRBAG ASSEMBLY LH (w/ Rear Seat Side Airbag) Installation
41. INSTALL UPPER CENTER PILLAR GARNISH LH Installation
42. INSTALL LOWER CENTER PILLAR GARNISH LH Installation
43. INSTALL REAR DOOR SCUFF PLATE LH Installation
44. INSTALL FRONT PILLAR GARNISH LH Installation
45. INSTALL SIDE INSTRUMENT PANEL LH Installation
46. INSTALL FRONT DOOR OPENING TRIM COVER LH Installation
47. INSTALL FRONT DOOR SCUFF PLATE LH Installation
48. INSTALL ROOF SIDE INNER GARNISH ASSEMBLY RH Installation
49. INSTALL REAR SEAT SIDE GARNISH RH (w/o Rear Seat Side Airbag) Installation
50. INSTALL REAR SEAT SIDE AIRBAG ASSEMBLY RH (w/ Rear Seat Side Airbag)
HINT: Use the same procedure for the RH side and the LH side.
51. INSTALL UPPER CENTER PILLAR GARNISH RH Installation
52. INSTALL LOWER CENTER PILLAR GARNISH RH Installation
53. INSTALL REAR DOOR SCUFF PLATE RH Installation
54. INSTALL FRONT PILLAR GARNISH RH Installation
55. INSTALL SIDE INSTRUMENT PANEL RH Installation
56. INSTALL FRONT DOOR OPENING TRIM COVER RH Installation
57. INSTALL FRONT DOOR SCUFF PLATE RH Installation
58. INSTALL FRONT SEAT ASSEMBLY LH Installation
59. INSTALL FRONT SEAT REAR OUTER TRACK BRACKET COVER LH Installation
60. INSTALL FRONT SEAT REAR INNER TRACK BRACKET COVER LH Installation
61. INSTALL FRONT SEAT OUTER TRACK BRACKET COVER LH Installation
62. INSTALL FRONT SEAT INNER TRACK BRACKET COVER LH Installation
63. INSTALL FRONT SEAT HEADREST ASSEMBLY (for Driver Seat)
64. CONNECT FRONT SEAT OUTER BELT ASSEMBLY LH Installation
65. INSTALL SEAT BELT ANCHOR COVER CAP LH Installation
66. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL
CAUTION: Wait for 90 seconds after disconnecting the cable to prevent airbag deployment.
67. INSTALL FRONT SEAT ASSEMBLY RH Installation
68. INSTALL FRONT SEAT REAR OUTER TRACK BRACKET COVER RH Installation
69. INSTALL FRONT SEAT REAR INNER TRACK BRACKET COVER RH Installation
70. INSTALL FRONT SEAT OUTER TRACK BRACKET COVER RH Installation
71. INSTALL FRONT SEAT INNER TRACK BRACKET COVER RH Installation
72. INSTALL FRONT SEAT HEADREST ASSEMBLY (for Front Passenger Seat)
73. CONNECT FRONT SEAT OUTER BELT ASSEMBLY RH Installation
74. INSTALL SEAT BELT ANCHOR COVER CAP RH Installation
75. INSTALL REAR SEATBACK ASSEMBLY Installation
76. INSTALL REAR CENTER SEAT HEADREST ASSEMBLY
77. INSTALL REAR SEAT HEADREST ASSEMBLY
78. INSTALL REAR SEAT CUSHION ASSEMBLY Installation
79. PERFORM INITIALIZATION
(a) Perform initialization Repair Instruction - Initialization.
HINT: Some systems need initialization after reconnecting the cable to the negative battery terminal.
80. INSPECT SHIFT LEVER POSITION Adjustments
81. ADJUST SHIFT LEVER POSITION Adjustments
82. INSPECT CURTAIN SHIELD AIRBAG ASSEMBLY Curtain Shield Airbag Assembly
83. INSPECT FRONT SEAT ASSEMBLY Installation
84. INSPECT SRS WARNING LIGHT
(a) Inspect the SRS warning light Diagnosis System.