Removing and Installing Sun Roof Lid

REMOVING AND INSTALLING SUN ROOF LID


Version without Plastic Gate.






Open sun roof completely
Remove left and right upper guide rails after unscrewing screws (1....5)
Loosen screw (6).

Installation:
Lubricate guide rails with Vaseline.
Use Terostat tape on front corners.






Close sun roof but for about 5cm (2").
Press off front roof liner frame.
Close sun root and push back roof liner frame completely.

Installation:
Close sun roof, pulling roof liner frame forward uniformly at same time.
Open sun roof slightly, holding roof liner frame by hand.
Press in clips for front roof liner frame.






Unscrew nuts (1....3) on left and right sides.
Remove sun roof lid.

Installation:
Attach sun roof lid on holder at rear, pulling in holder slightly.
Open sun roof by hand and with help of gearbox.

Caution!
Don't clamp roof liner frame.







Installation:
Check left and right slides, replacing if necessary.
Adjust sun roof.

Version with Plastic Gate






Close sun roof but for about 5cm (2")

Press off front roof liner frame.
Close sun roof and push back roof liner frame completely.

Installation:
Close sun Roof.
Pull roof liner frame forward uniformly.
Open sun roof slightly, holding roof liner frame by hand
Press in clips for front roof liner frame.






Unscrew left and right bolts
Lift off sun roof lid.

Installation:
Adjust sun roof.

Note:
Replace self-locking bolts.
Tool = Torx wrench T 25.