AW55-50 / AWD50 Transmission

Gear selector lever assembly, replacing

Note! As the illustrations in this service information are used for different model years and / or models, some variation may occur. However, the essential information in the illustrations is always correct.

Removal

Removing the center console

V70R (B5254T4 engine)
Remove the center console. See.

V70 (other engines)
Remove the center console. See (-2004) or (2005-).

V70XC/XC70
Remove the center console. See (-2004) or (2005-).

S80
Remove the center console. See Center console, replacing Center Console, Replacing.

Removing the gear selector knob
Remove the gear selector knob. See Gear selector knob, replacing Gear Selector Knob, Replacing.

Removing the top panel from the gear selector assembly
Remove the top panel. See Printed circuit board gear selector assembly/top panel, replacing Printed Circuit Board Gear Selector Assembly/Top Panel, Replacing.

Removing the gear selector assembly and cables





Remove:
- the catch for the cable at the gear selector lever
- the cable from the end of the gear selector assembly
- the key lock cable. Pry out the yellow locking sleeve slightly. Lift the cable up from the gear selector assembly
- the 4 screws.





Removing the solenoid
Transfer the solenoid and connector to the new gear selector unit

Installation

Note! For tightening torques, Tightening Torque.

Installing the gear selector assembly and mechanical cables




Tighten to 25 Nm.

Install:
- the mechanical cable to the gear selector. Secure the cable with the catch
- cable on the gear selector nose
- the key lock cable to the gear selector assembly.
Place the cable in the extracted locking sleeve the cable will be adjusted).

Initial setting of the key lock cable (adjusting)
See Gear selector lever assembly Geartronic, replacing Gear Selector Lever Assembly Geartronic, Replacing.

Installing the top panel on the gear selector assembly
Install the top panel and boot. See Printed circuit board gear selector assembly/top panel, replacing Printed Circuit Board Gear Selector Assembly/Top Panel, Replacing.

Installing gear selector knob
Install the gear selector knob. See Gear selector knob, replacing Gear Selector Knob, Replacing.

Installing the center console

V70R (B5254T4 engine)
Install the center console. See.

V70 (other engines)
Install the center console. See (-2004) or (2005-).

V70XC/XC70
Install the center console. See (-2004) or (2005-).

S80
Install the center console. See Center console, replacing Center Console, Replacing.