Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 220 - Fuel Pump Replacement
- Recall 10V566000: Potential GPS Battery Fires
- Recall 220 - Inspect/Replace Fuel Pump
- Recall 04V029000: Potential Control Arm Separation
- Recall - Potential Control Arm and Spindle Separation
- Recall 07V226000: Fuel Pressure Sensor Replacement
- Recall 09V483000: Fuel Pump Replacement
- Recall 231 - Potential GPS Battery Over Heating
- Customer Interest
- Drivetrain - DEM Software Updates
- Audio/Computer/Controls/Fuel System - AM Radio Static
- ABS/TCS - BCM, DTC 0076 & BCM 0117 Set After SW Update
- Navigation System - SW Upgrade Disc Guide
- Navigation System - Various Malfunctions
- Entertainment System - DTC AUM-46FE Stored
- Drivetrain - Front Hub Click Noise At Take Off
- Antitheft - False Alarm Information
- Audio - Background Noise When Using Various Devices
- A/C - Musty Odors From Vents
- Brakes - Front and Rear Brakes Squeal
- Engine - Runs Rough/MIL ON/Misfire DTC's/Low Power
- Instruments - Erratic Trip Meter Operation On DIM
- Suspension - Rear Shock Noise On Small Bumps
- Drivetrain/Wheels - Wheel Bolts Corroding
- Body/Frame - Knocking/Clicking Noise On Turns
- Drivetrain - Front Axle Pinging Noise On Garage Shifts
- ABS/TCS - DTC's 0076 and 0117
- Engine Controls - Cooling Fan On/DTC 2000 Set
- Engine Control - DTC 250A, 2200/220A/Driveability Issues
- M/T - 1st/Reverse Gear Difficult to Engage
- Lighting - Xenon Headlamps Inoperative
- Steering/Suspension - BCM Codes 0121 And 0127
- A/T AW55 - TCM DTC's 010A, 010B, 010C
- Engine - Knock/Rattles/Low Power/DTC's Set
- Audio System - Poor AM Reception
- Body/Frame - Squeaking/Crunching Noise When Wet/Cold
- Interior - Front Seat Noise/Rocking Motion
- Audio System - AM Static Caused By PEM, Turbo Cars Only
- Fuel System - Fuel Filler Neck Loose at Grommet
- Interior - Front Seat Loose/Play/Clicking Noise
- Steering - Knocking/Thumping/Clicking Noises
- Exhaust System - Squealing/Pinging Noises
- A/C, Interior - Whistle From Right Side of Dash
- Steering - ZF System Fault Tracing And Repair
- Interior - Holes in Passenger Side Carpet
- DVD Player - Won't Accept/Eject DVD's/Inoperable
- Steering - Power Steering Reservoir Fluid Leak
- Interior - Power Seat Rocks Fore/Aft on Accel/Decel
- A/C - System Odors/Afterblow Function
- Computers/Controls - TCM/DEM Software Updates
- Steering - Vehicle Pull On Acceleration/Cruise
- Fuel System - Starting Problems Parked on a Downhill
- Drivetrain - Fluid Leakage From The Angle Gear
- A/C - Climate Control System Cleaning
- A/T - Coolant Contamination Information
- Wheels/Tires - Vibration While Driving
- Steering - Intermittent Lack Of Power Steering Assist
- Body - Front/Rear Door Weatherstrips Come Loose
- Drivetrain - Rear Differential Leaking And Resealing
- Global Positioning - Erratic Garmin(R) 765 Operation
- Suspension - Front Suspension Resonating Noise
- Wheels/Hubs - Vibrations While Driving
- M/T - Rattle Noise From Dual Mass Flywheel
- Suspension - Front End Knocking Noises
- A/T Controls - TCM Update For Various Concerns
- Anti-Theft - Keyless Drive Receiver Issues
- Superceded Bulletins
- SB39-004 - 04/16/08
- SB77-013 - 10/29/10
- SB77-006 - 01/13/11
- TNN59-13 - 02/01/08
- TJ16701 - 12/20/07
- TJ22721 - 10/05/10
- TJ19245 - 03/22/10
- TJ15493 - 06/02/10
- TJ22721 - 03/18/10
- TJ16514 - 08/05/09
- TJ16761 - 03/13/2009
- TJ16773 - 01/16/09
- 605500 - 11/01/07
- TJ16506 - 06/18/08
- TJ19624 - 10/01/08
- TNN43-48 - 04/18/07
- TNN35-09 - 01/26/08
- TNN28-74 - 07/013/07
- TNN37-22 - 11/30/01
- TNN28-74 - 05/01/07
- TNN40-02 - 06/21/06
- TNN85-53 - 11/01/05
- TNN59-11 - 12/17/03
- TNN30-04 - 10/11/05
- TNN21-21 - 05/09/05
- TNN77-08 - 08/29/03
- TNN76-04 - 01/22/04
- TNN36-38 - 02/04/03
- TNN23-23 - 02/13/04
- Interior - Power Seat Fore And Aft Rocking Motion
- Audio System - Stuck CD's in Audio Units
- Audio System - CD Stuck in Audio Unit
- Navigation System - Software Disc Upgrade
- Navigation System - RTI Navigation Identification Guide
- Navigation System- SW Upgrade Disc Guide
- Navigation System -SW Upgrade Disc Guide
- Navigation System - SW Upgrade Disc Guide
- Navigation System - Software Disc SW Upgrade
- Navigation System - RTI System Operates Erratically
- Navigation System -Various Malfunctions
- Navigation System - Various Malfunctions
- Navigation System- Various Malfunctions
- Antitheft - False Alarm Information
- A/C - Cleaning for System Odors
- Suspension - Front Strut Knocking Noises
- Steering - ZF Power Steering Diagnosis And Repair
- Steering - Power Steering Fluid Leak at Reservoir
- Power Steering - Fluid Leak From Reservoir
- Drivetrain - Angle Gear Fluid Leakage
- TNN46-13 - 02/11/08
- M/T - Hard to Engage 1st/Reverse Gear
- Drivetrain - Front Driveshaft CV Joint Service
- A/T - Cooler/Line Flushing Guidelines
- A/T - Cooler/Line Flushing When Replacing A/T
- Drivetrain Controls - Software Update For Various Issues
- Recall 220 - Fuel Pump Replacement
- Recall 220 - Fuel Pump Inspection/Replacement
- Fuel System - Hard Start When Parked Downhill
- A/T Controls - TCM Updates For Various Concerns/Issues
- A/T Controls -TCM Updates For Various Concerns/Issues
- A/T Controls - TCM Updates For Various Concerns/Issues
- Drivetrain Controls - Software Update For Various Issues
- A/T Controls- TCM Updates For Various Concerns/Issues
- A/T Controls -TCM Updates For Various Issues
- Drivetrain Controls - DEM Update For Various Issues
- A/T Controls - TCM Updates For Various Issues/DTC's
- Drivetrain Controls DEM Update For Various Issues
- Emissions - Improved EVAP Leak Detection Diagnostics
- Engine Controls - MIL ON/DTC 4308/434C/P044200 Set
- A/T Controls - TCM Upgrades For Various Issues/DTC's
- Drivetrain Controls - Jolting/Various DTC's
- Engine Controls - MIL ON/DTC 4308/434C/P044200
- Emissions - EVAP Leakage Detection Diagnostics
- Engine Controls - Software Update for EVAP DTC's
- TNN28-74 - 12/04/07
- TNN28-74 - 08/24/07
- Engine Controls - EVAP System DTC's
- TNN28-74 - 05/07/07
- Engine, A/T Controls - DEM and TCM Software Updates
- Engine/A/T Controls - ECM/TCM Upgrade for Various Issues
- A/T, Engine Controls - Software Upgrades
- Emissions - Improved EVAP Leak Detection Diagnostics
- A/T Controls - TCM Updates For Various Concerns/Issues
- A/T Controls - TCM Update For Various Concerns
- Driveline/Exhaust - High Pitched Squealing Noise
- Cooling System - A/T Fluid/Engine Oil Contamination
- Engine - Runs Rough/MIL ON/Misfire DTC's Set
- Engine - MIL ON/Misfire DTC's Set/Rough Idle/Low Power
- A/C - Musty Odors
- A/T - Engine Coolant Contamination Detection
- Steering - Alignment Specifications
- Transmission/Drivetrain - Lubricants And Fluids
- Steering/Suspension - Wheel Alignment Specifications
- Wheels/Tires - Vibration Diagnosis
- SB77-013 - 09/14/11
- Engine - Required Engine Oils And Maintenance Intervals
- All Technical Service Bulletins
- Drivetrain - DEM Software Updates
- Audio/Computer/Controls/Fuel System - AM Radio Static
- Memory Systems - Restoring Customer Preferred Settings
- Audio System - CD's Stuck In Audio Units
- ABS/TCS - BCM, DTC 0076 & BCM 0117 Set After SW Update
- Tires/Wheels - Tire Rotation Recommendations
- Wheels - Wheel Cross Reference
- Electrical - Battery Current Consumption And RDAR
- Emissions - EVAP Leak Detection Diagnostic Improvements
- Navigation System - SW Upgrade Disc Guide
- Navigation System - Various Malfunctions
- Entertainment System - DTC AUM-46FE Stored
- Recall 220 - Fuel Pump Replacement
- Tires - Recommended Winter Tires (United States)
- Wheels - Winter Wheel Applications (USA, Canada)
- Drivetrain - Front Hub Click Noise At Take Off
- Tires - Recommended Winter Tires (Canada)
- Antitheft - False Alarm Information
- Body Controls - BCM Diagnostic Information
- Fuel System - E10 Petrol Fuel Requirements
- Audio - Background Noise When Using Various Devices
- Starting System - Ign. Key Won't Turn Past Position 1
- Electrical - Lead Acid Battery Handling Precautions
- Steering - ZF Power Steering Fault Tracing
- Recall 10V566000: Potential GPS Battery Fires
- Recall 220 - Inspect/Replace Fuel Pump
- Vehicle - Platform Identification
- Vehicle - Type and Platform Identification
- A/C - Musty Odors From Vents
- Brakes - Front and Rear Brakes Squeal
- Engine - Runs Rough/MIL ON/Misfire DTC's/Low Power
- Instruments - Erratic Trip Meter Operation On DIM
- Recall 04V029000: Potential Control Arm Separation
- Recall - Potential Control Arm and Spindle Separation
- Engine - Rear Main Seal Replacement
- Steering/Suspension - New Ball Joint/Torqueing Method
- Steering/Suspension - Revised Ball Joint Installation
- Suspension - Rear Shock Noise On Small Bumps
- Drivetrain/Wheels - Wheel Bolts Corroding
- Body/Frame - Knocking/Clicking Noise On Turns
- Interior - Headliner Clip Replacement
- Drivetrain - Front Axle Pinging Noise On Garage Shifts
- ABS/TCS - DTC's 0076 and 0117
- Engine Controls - Software Download Fault Prevention
- Engine Controls - Cooling Fan On/DTC 2000 Set
- Engine Control - DTC 250A, 2200/220A/Driveability Issues
- Cell Phone - Bluetooth Hands Free Kit Information
- M/T - 1st/Reverse Gear Difficult to Engage
- Lighting - Xenon Headlamps Inoperative
- Body - Waste Paper Basket Mounting
- SRS - Electrical Diagram Correction
- Antitheft System - Immobilizer System Overview
- Steering/Suspension - BCM Codes 0121 And 0127
- A/T AW55 - TCM DTC's 010A, 010B, 010C
- Body - Rear Bumper Casing
- A/T, M/T, AWD - Approved Lubricants
- Engine - Knock/Rattles/Low Power/DTC's Set
- Body - Front Wing Liner, Adjustment
- Body - PUR Bond(R) Window Bonding
- Wipers/Washers - Rain Sensor Function/Limitations
- A/T/Ignition - Shift Interlock Cable Clip Service
- Audio System - Poor AM Reception
- Body/Frame - Squeaking/Crunching Noise When Wet/Cold
- Interior - Front Seat Noise/Rocking Motion
- Interior - Front Seat Slide Rail Adjustment
- Audio System - AM Static Caused By PEM, Turbo Cars Only
- Fuel System - Fuel Filler Neck Loose at Grommet
- Interior - Front Seat Loose/Play/Clicking Noise
- Power Steering - ECPS System Diagnostics
- Steering - Knocking/Thumping/Clicking Noises
- Air Bag System - System Life Expectancy
- A/T, M/T - Parts Transfer When Replacing Trans Assembly
- BULLETIN CANCELLATION NOTICE
- Engine Controls - Engine Management Software Usage
- Exhaust System - Squealing/Pinging Noises
- A/C, Interior - Whistle From Right Side of Dash
- Steering - ZF System Fault Tracing And Repair
- Interior - Holes in Passenger Side Carpet
- Recall 07V226000: Fuel Pressure Sensor Replacement
- DVD Player - Won't Accept/Eject DVD's/Inoperable
- Engine - Exchange Cylinder Block Modification
- Tires - Pressure Requirements/Recommendations
- Computers/Controls - CANbus Network Information
- Steering - Power Steering Reservoir Fluid Leak
- Interior - Power Seat Rocks Fore/Aft on Accel/Decel
- A/C - System Odors/Afterblow Function
- Computers/Controls - TCM/DEM Software Updates
- Steering - Vehicle Pull On Acceleration/Cruise
- Navigation System - RTI Identification Guide
- Engine - Lubrication System Contamination Cleaning
- Fuel System - Starting Problems Parked on a Downhill
- M/T - Revised Clutch Shock Limiter
- Fuel System - Fuel Pump Control Module Replacement
- Drivetrain - Fluid Leakage From The Angle Gear
- Lighting - Halogen Headlamp Bulb Replacement Info.
- A/C - Climate Control System Cleaning
- Steering - ZF Steering Gear Fluid Line Replacement
- Drivetrain - Revised Driveshaft Removal/Installation
- A/T - Coolant Contamination Information
- Cell Phone - Bluetooth(R) Software Upgrade Information
- Audio System - Stuck CDs in Audio System
- Wheels/Tires - Vibration While Driving
- Steering - Intermittent Lack Of Power Steering Assist
- Body - Front/Rear Door Weatherstrips Come Loose
- Blind Spot Information Sys.(BLIS) - Function/Diag. Guide
- Engine - Pressure Washing Precautions
- Recall 09V483000: Fuel Pump Replacement
- Drivetrain - Rear Differential Leaking And Resealing
- A/T - Cooler/Line Flushing Information
- Global Positioning - Erratic Garmin(R) 765 Operation
- Fuel System - Fuel Pump Warranty Extension
- Suspension - Front Suspension Resonating Noise
- Wheels/Hubs - Vibrations While Driving
- M/T - Rattle Noise From Dual Mass Flywheel
- Computers/Controls - Usage of RELOAD Software
- Steering/Suspension - Alignment Specifications
- Suspension - Front End Knocking Noises
- Recall 231 - Potential GPS Battery Over Heating
- Engine Controls - Reuse Of ECM's
- Instruments - Tachometer Stuck After Software Update
- A/T Controls - TCM Update For Various Concerns
- Computers/Controls - Programming And Diagnosis
- Transmission/Drivetrain - Lubricants And Fluids
- Engine/Drive Train - Best Before Date Use For Gasket Sealants
- Charging System - Prior Approval For Alternator Replacement
- Anti-Theft - Keyless Drive Receiver Issues