Chassis Number 26213 - 999999
Signal too low
Checking the transmission input speed sensor signal
- Start the engine and let it run at idle speed
- Gear selector in position P
- Read off the transmission input speed.
Check that the transmission speed is updated.
Compare with the engine speed (RPM).
Is the speed updated?
Yes - Intermittent fault
No - Checking wiring and sensors
-------------------------------------------------
Checking wiring and sensors
- Ignition off.
Check the transmission control module (TCM) and transmission input speed sensor connectors. Check for contact resistance and oxidation according to Checking wiring and terminals. Permanent fault Checking Wiring and Terminals. Permanent Fault.
Check the power supply cable between control module terminal #A59 (#A59) and transmission connector terminal #A2. Check for an open-circuit according to Checking wiring and terminals. Permanent fault Checking Wiring and Terminals. Permanent Fault. Check for a short-circuit to ground according to Checking wiring and terminals. Permanent fault Checking Wiring and Terminals. Permanent Fault.
Check the signal cable between control module terminal #A41 (#A41) and transmission connector terminal #A1. Check for an open-circuit according to Checking wiring and terminals. Permanent fault Checking Wiring and Terminals. Permanent Fault. Check for a short-circuit to ground according to Checking wiring and terminals. Permanent fault Checking Wiring and Terminals. Permanent Fault.
Hint: With the control module connected, the ignition on and a voltmeter connected between transmission connector terminals #A2 and #A1 (control module side), the voltage must be 1-3 V below Ubat.
Remedy as necessary.
Other information:
- To connect the breakout box, see Connecting the breakout box, B5244T5, B5254T2 Connecting the Breakout Box
- To disconnect the control module, see Transmission control module (TCM), replacing, B5244T5, AW55-50/51SN, B5254T2, AW55-50/51SN, B5254T2, AW50/51 AWD Service and Repair
- To disconnect the transmission connector, see Connectors, transmission, disconnecting / connecting, B5244T5, AW55-50/51SN, B5254T2, AW55-50/51SN, B5254T2, AW50/51 AWD Procedures
- To check and replace the transmission speed sensor, see Replacing the transmission input speed sensor and the transmission output speed sensor Input Speed Sensor/Output Speed Sensor, Replacing
- For information about signals, see Signal description. Transmission control module (TCM), AW50/51 AWD, AW55-50/51SN Signal Description. Transmission Control Module (TCM).
Continue - Verification
-------------------------------------------------
Verification
Verification
Hint: After carrying out the repair, check that the fault has been remedied.
- Ignition off.
- Reinstall the connectors, components etc.
- Start the engine and let it idle.
- Gear selector in position P.
- Read off the transmission speed.
Depress the accelerator pedal (AP) and check that engine speed (RPM) is updated.
Compare with the engine speed (RPM).
Is the speed updated?
Yes - VERIFIED
No - VERIFICATION FAILEDPAPER
------------------------
VERIFIED - Fault Found
VERIFICATION FAILED - Fault-tracing information
PAPER - No Fault Found
-------------------------------------------------
Fault-tracing information
Information
Fault-tracing information
The fault should have been detected and remedied. As this is not the case fault-tracing has failed.
Exit fault-tracing for this diagnostic trouble code (DTC) or make another attempt.
Do you want to exit fault-tracing?
Yes - FAULT-TRACING FAILED
No - Attempt New Test
------------------------
FAULT-TRACING FAILED - FAULT-TRACING FAILED
Attempt New Test - Checking the transmission input speed sensor signal
-------------------------------------------------
Intermittent fault
- Ignition off.
Check the control module and transmission input speed sensor connectors. Check for contact resistance and oxidation according to Checking wiring and terminals. Intermittent faults Checking Wiring and Terminals. Intermittent Faults.
Check the power supply cable between control module terminal #A59 (#A59) and transmission connector terminal #A2. Check for an intermittent open-circuit according to Checking wiring and terminals. Intermittent faults Checking Wiring and Terminals. Intermittent Faults. Check for an intermittent short-circuit to ground according to Checking wiring and terminals. Intermittent faults Checking Wiring and Terminals. Intermittent Faults.
Check the signal cable between control module terminal #A41 (#A41) and transmission connector terminal #A1. Check for an intermittent open-circuit according to Checking wiring and terminals. Intermittent faults Checking Wiring and Terminals. Intermittent Faults. Check for an intermittent short-circuit to ground according to Checking wiring and terminals. Intermittent faults Checking Wiring and Terminals. Intermittent Faults.
Remedy as necessary.
Other information:
- To connect the breakout box, see Connecting the breakout box, B5244T5, B5254T2 Connecting the Breakout Box
- To disconnect the control module, see Transmission control module (TCM), replacing, B5244T5, AW55-50/51SN, B5254T2, AW55-50/51SN, B5254T2, AW50/51 AWD Service and Repair
- To disconnect the transmission connector, see Connectors, transmission, disconnecting / connecting, B5244T5, AW55-50/51SN, B5254T2, AW55-50/51SN, B5254T2, AW50/51 AWD Procedures
- For information about signals, see Signal description. Transmission control module (TCM), AW50/51 AWD, AW55-50/51SN Signal Description. Transmission Control Module (TCM).
Continue - Fault-tracing information
-------------------------------------------------
Fault-tracing information
Information
Fault-tracing information
If the fault is intermittent, do not verify fault-tracing if the fault does not recur.
It is possible to view the information again, or leave fault-tracing for this diagnostic trouble code (DTC).
Do you want to view the information again?
Yes - Attempt New Test
No - Fault Found
------------------------
Attempt New Test - Checking the transmission input speed sensor signal
FAULT FOUND - Fault Found
-------------------------------------------------