FREE REPAIR MANUALS & LABOR GUIDES 1982-2013 Vehicles
Courtesy of Operation CHARM: Car repair manuals for everyone.

Clutch Pedal Position Sensor / Switch: Service and Repair






Clutch Position Sensor G476

Special tools, testers and auxiliary items required

Hose Clamps up to 25 mm Dia. (3094)

Removing

- First, check whether a coded radio is installed. If so, obtain the anti-theft code.

- Turn off the ignition and disconnect the battery ground cable.

- Remove the entire air filter housing, if it is located near the battery.

- Remove the battery and the battery tray.






If a hose/line assembly - 1 - with a round component is installed directly below the master cylinder, the hose/line assembly must be removed.

While performing the following procedure, make sure no brake fluid comes into contact with the longitudinal member or the transmission. If it does, clean the area thoroughly.

- Place a lint free cloth under the master cylinder.

- Clamp off the supply hose to the master cylinder using a hose clamp up to 25 mm dia. (3094).






- Using a screwdriver or a pointed tool, pull out the clip - 2 - until it stops.






- Remove the hose/line assembly - 1 - or pipe from the clutch master cylinder and seal it off.

- Disconnect the connector - 4 -.

- Unclip the clutch position sensor from the master cylinder - arrow - and remove it.

Ignore - item 3 -.

Installing

Install in the reverse order of removal. Note the following:

Replace the hose clamps

Refer to the Parts Catalog.

If the hose/line assembly was removed:

- Install the hose/line assembly - 1 - or pipe with a seal - 2 - into the clutch master cylinder connection - 4 - until the clip - 3 - audibly engages.






- Pull on the hose/line assembly or pipe to make sure it is secure.

- After removing the hose clamp up to 25 mm dia. (3094) , bring the supply hose back to its original shape.

- Bleed the clutch system. Refer to => [ Clutch System, Bleeding ] Procedures.

- Install the battery tray and the battery.

- Install the entire air filter housing, if it is located near the battery.

- Connect the battery and follow the steps for after connecting the battery.