FREE REPAIR MANUALS & LABOR GUIDES 1982-2013 Vehicles
Courtesy of Operation CHARM: Car repair manuals for everyone.

Oil Pressure Sender: Testing and Inspection






Oil Pressure and Switch, Checking

Special tools, testers and auxiliary items required

Oil pressure gauge (VAG 1342)

Voltage tester (VAG 1527B)

Connector test set (VAG 1594C)

Vehicle diagnostic tester

Engine oil level OK.

Engine oil temperature at least 80° C (176° F) (radiator fan must start up once)

- Bring the lock carrier into service position. Radiator Support

- Support the lock carrier using a sleeve - B -, 80 millimeters (mm) in length, for example, from (VW 540/1A) and a M8 x 100 bolt - A -.





- Remove the oil pressure switch (F1) and install it into the (VAG 1342).





- Install the (VAG 1342) into the oil filter bracket in place of the oil pressure switch.

- Connect the brown wire of the (VAG 1342) to ground (GND).

- Connect the (VAG 1527B) using adapter cables from (VAG 1594C) to B+ and the oil pressure switch.

Light Emitting Diode (LED) must not light up.

- If LED lights up, replace the oil pressure switch (1.4 bar).

If the LED does not light up:

- Start the engine and increase the engine speed.

The LED must illuminate at 1.2 to 1.6 bar. Replace the oil pressure switch if it does not.

- Increase engine speed further.

At higher engine speeds the oil pressure must not exceed 7.0 bar

At 2000 RPM and an oil temperature of 80 °C (176 °F), the oil pressure must be 2.7 to 4.5 bar.



If the specification is not obtained:

- Check the screen in the oil intake pipe for contamination.

Also, mechanical damage, for example, bearing damage can also be the cause of too low oil pressure.

If no malfunction can be found:

- Replace the oil pump. Refer to one of the following:

=> [ Oil Pump, through MY 2007 ] Oil Pump, Through MY 2007.

=> [ Oil Pump, from MY 2008 ] Oil Pump, From MY 2008.

If the specification is exceeded:

- Check the oil passages.

- Replace the oil filter bracket if necessary.