Installation
SEAT BELT: REAR SEAT OUTER BELT ASSEMBLY:
COMPONENTS
INSTALLATION
1. INSTALL REAR SEAT 3 POINT TYPE BELT ASSEMBLY
NOTE: Do not disassemble the retractor.
(a) Before installing the ELR, check the ELR.
(1) Gently tilt the ELR and pull the belt. Check that the belt will not lock within 15° of tilt in all directions Then check that the belt will lock when over 45° of tilt is applied.
If the operation is not as specified, replace the rear seat belt assembly outer.
(b) Install the rear seat belt assembly outer (retractor side) with the bolt.
for upper bolt - Torque: 4.9 Nm (50 kgf-cm, 43 in-lbf)
for lower bolt - Torque: 41.2 Nm (420 kgf-cm, 30 ft-lbf)
(c) Install the rear seat belt assembly outer (floor anchor side) with the bolt.
Torque: 41.2 Nm (420 kgf-cm, 30 ft-lbf)
NOTE: Do not make the anchor part run onto the protruding part of the floor panel.
(d) After installing the ELR, check the ELR.
NOTE: The check should be performed with the assembly installed.
(1) With the belt installed, check that the belt locks when it is pulled out quickly.
If the operation is not as specified, replace the rear seat belt assembly outer.
(e) Check the fastening function of the child restraint system.
NOTE: The check should be performed with the assembly installed.
(1) When the belt is pulled put fully, the belt should automatically try to retract.
(2) After the belt has fully retracted, the belt should be able to be pulled out and retracted again. If the operation is not as specified, replace the rear seat belt assembly outer.
2. INSTALL DECK TRIM SIDE PANEL ASSEMBLY LH
3. INSTALL DECK TRIM SIDE PANEL ASSEMBLY RH
4. INSTALL REAR SEAT SIDE GARNISH LH
5. INSTALL REAR SEAT SIDE GARNISH RH
6. INSTALL REAR SEAT CUSHION ASSEMBLY AND REAR SEATBACK ASSEMBLY
7. INSTALL DECK TRIM COVER REAR
8. INSTALL BACK DOOR WEATHERSTRIP
9. INSTALL LUGGAGE COMPARTMENT TRAY
10. INSTALL DECK FLOOR BOX REAR
11. INSTALL DECK BOARD SUB-ASSEMBLY
12. INSTALL DECK BOARD NO. 2
13. INSTALL TONNEAU COVER ASSEMBLY
14. INSTALL REAR DOOR OPENING TRIM LH
15. INSTALL REAR DOOR OPENING TRIM RH
16. INSTALL REAR DOOR SCUFF PLATE LH
17. INSTALL REAR DOOR SCUFF PLATE RH