Emissions - MIL ON/DTC P2420 Set
S-SB-0018-10July 19, 2010
MIL "ON" DTC P2420
Service Category
Vehicle Interior
Section
Meter/Gauge/Display
Market
USA
Applicability
Introduction
Some 2010 model year xB, xD, and tC vehicles may exhibit a MIL "ON" condition with Diagnostic Trouble Code (DTC) P2420 stored. Use the following repair procedure to diagnose and repair this condition.
Production Change Information
This TSB applies to vehicles produced WITHIN the Production Change Effective VINs shown below.
Parts Information
Warranty Information
APPLICABLE WARRANTY
^ This repair is covered under the Toyota Federal Emission Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from the vehicle's in-service date.
^ For California specification tC vehicles sold, registered, and operated in California, Connecticut, Maine, Massachusetts, New Jersey, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington, the charcoal canister is covered under the California Emission Warranty. This warranty is in effect for 36 months or 50,000 miles, whichever occurs first, from the vehicle's In-service date.
^ For California specification xB and xD vehicles sold, registered, and operated in California, Connecticut, Maine, Massachusetts, New Jersey, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington, the charcoal canister is covered under the California Emission Warranty. This warranty is in effect for 84 months or 70,000 miles, whichever occurs first, from the vehicle's in-service date.
^ Warranty application is limited to occurrence of the specified condition described in this bulletin.
Required Tools & Equipment
Repair Procedure
1. Using TIS Techstream check for Diagnostic Trouble Codes (DTCs).
2. Are codes other than P2420 present?
^ YES - Diagnose other DTC(s) first.
^ NO - Continue to step 3.
3. Replace the charcoal canister assembly.
Refer to the Technical Information System (TIS) applicable model and model year Repair Manual:
^ 2010 xB:
Engine/Hybrid System - Emission Control - "2AZ-FE Emission Control: Canister: Removal / Installation"
^ 2010 xD:
Engine/Hybrid System - Emission Control - "2ZR-FE Emission Control: Canister: Removal / Installation"
^ 2010 tC:
Engine/Hybrid System - Emission Control - "2AZ-FE Emission Control: Canister: Removal / Installation"
4. Confirm the repair.