Electrical - Multiple Warning Lamps/No Shift From Park

S-SB-0031-09

June 12, 2009

IG1 Relay Freezing

Service Category
Power Source/Network

Section
Networking

Market
USA





Applicability

Introduction

Some 2005 - 2009 tC and 2008 - 2009 xD and xB vehicles may exhibit a condition with multiple warning lights illuminated vehicle not shifting from park to drive and/or other accessories becoming inoperative after the vehicle has cold soaked in sub-freezing (below 14°F [-10°C]) ambient air temperature. A newly designed relay has been made available to address this concern.





Parts Information





Warranty Information

APPLICABLE WARRANTY

^ This repair is covered under the Toyota Comprehensive Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from the vehicle's in-service date.

^ Warranty application is limited to correction of a problem based upon a customer's specific complaint.




Required Tools & Equipment

Additional TIS Techstream units may be ordered by calling Approved Dealer Equipment (ADE).

Repair Procedure





1. Locate the instrument panel Junction Block No.1 in the instrument panel as shown in Figure 1.

2. Remove the relay and verify the part number located on the side of the relay.

A. If the part number is NOT 90987-02031 then replace the relay with the countermeasure relay.

B. If the part number is 90987-02031 then diagnose the specific conditions reported by the customer or based on MIL "ON" codes that are stored and follow the Repair Manual.

3. Connect TIS Techstream and clear any stored DTCs.