Removal

2ZR-FE COOLING: WATER PUMP: REMOVAL

REMOVAL

1. DISCHARGE FUEL SYSTEM PRESSURE Vehicle Damage Warnings
2. REMOVE BATTERY Removal

3. REMOVE BATTERY TRAY
4. REMOVE FRONT WHEELS
5. REMOVE ENGINE UNDER COVER LH
6. REMOVE ENGINE UNDER COVER RH
7. DRAIN ENGINE COOLANT Service and Repair

8. REMOVE FRONT WIPER ARM HEAD CAP

9. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY LH

10. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY RH

11. REMOVE HOOD TO COWL TOP SEAL

12. REMOVE COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY

13. REMOVE COWL TOP VENTILATOR LOUVER LH

14. REMOVE FRONT WIPER MOTOR AND LINK

15. REMOVE FRONT AIR SHUTTER SEAL RH Removal

16. REMOVE OUTER COWL TOP PANEL Removal

17. REMOVE AIR CLEANER ASSEMBLY Removal

18. REMOVE AIR CLEANER BRACKET Removal

19. REMOVE BATTERY CARRIER Removal

20. REMOVE NO. 2 CYLINDER HEAD COVER Removal

21. REMOVE FAN AND GENERATOR V BELT Removal

22. REMOVE NO. 2 RADIATOR HOSE Removal

23. DISCONNECT NO. 1 RADIATOR HOSE Removal

24. REMOVE FRONT BUMPER COVER

25. DISCONNECT NO. 1 OIL COOLER OUTLET HOSE (for Automatic Transaxle) Removal

26. DISCONNECT NO. 2 OIL COOLER INLET HOSE (for Automatic Transaxle) Removal

27. REMOVE HOOD LOCK ASSEMBLY Removal

28. REMOVE NO. 1 COOLER COVER Removal

29. REMOVE UPPER RADIATOR SUPPORT ABSORBER

30. REMOVE UPPER RADIATOR SUPPORT SUB-ASSEMBLY Removal

31. REMOVE RADIATOR ASSEMBLY Removal

32. SEPARATE WITH PULLEY COMPRESSOR ASSEMBLY

33. SEPARATE TRANSMISSION CONTROL CABLE ASSEMBLY (for Automatic Transaxle) Removal

34. SEPARATE TRANSMISSION CONTROL CABLE ASSEMBLY (for Manual Transaxle) Removal

35. SEPARATE UNION TO CHECK VALVE HOSE Removal

36. SEPARATE NO. 1 FUEL VAPOR FEED HOSE Removal

37. DISCONNECT ENGINE WIRE Removal

38. DISCONNECT HEATER WATER OUTLET HOSE A(FROM HEATER UNIT) Removal

39. DISCONNECT HEATER WATER INLET HOSE A Removal

40. DISCONNECT FUEL TUBE SUB-ASSEMBLY Removal

41. SEPARATE CLUTCH RELEASE CYLINDER ASSEMBLY (for Manual Transaxle) Removal

42. REMOVE COLUMN HOLE COVER SILENCER SHEET

43. SEPARATE STEERING SLIDING YOKE SUB-ASSEMBLY

44. SEPARATE NO. 1 STEERING COLUMN HOLE COVER SUB-ASSEMBLY

45. REMOVE SHIFT LEVER KNOB SUB-ASSEMBLY (for Manual Transaxle)

46. REMOVE CONSOLE PANEL UPPER

47. REMOVE CONSOLE BOX REAR COVER

48. REMOVE CONSOLE BOX CARPET

49. REMOVE REAR CONSOLE BOX SUB-ASSEMBLY

50. REMOVE FRONT CONSOLE BOX

51. REMOVE FRONT FLOOR BRACE CENTER Removal

52. REMOVE FRONT EXHAUST PIPE ASSEMBLY Removal

53. REMOVE FRONT AXLE SHAFT LH NUT Removal

54. REMOVE FRONT AXLE SHAFT RH NUT
HINT: The removal procedure for the RH side is the same as that for the LH side.

55. SEPARATE SPEED SENSOR FRONT LH Removal

56. SEPARATE SPEED SENSOR FRONT RH
HINT: The removal procedure for the RH side is the same as that for the LH side.

57. SEPARATE TIE ROD END SUB-ASSEMBLY LH Removal

58. SEPARATE TIE ROD END SUB-ASSEMBLY RH
HINT: The removal procedure for the RH side is the same as that for the LH side.

59. SEPARATE FRONT STABILIZER LINK ASSEMBLY LH Removal

60. SEPARATE FRONT STABILIZER LINK ASSEMBLY RH
HINT: The removal procedure for the RH side is the same as that for the LH side.

61. SEPARATE FRONT LOWER SUSPENSION ARM SUB-ASSEMBLY LH Removal

62. SEPARATE FRONT LOWER SUSPENSION ARM SUB-ASSEMBLY RH
HINT: The removal procedure for the RH side is the same as that for the LH side.

63. SEPARATE FRONT AXLE ASSEMBLY LH Removal

64. SEPARATE FRONT AXLE ASSEMBLY RH
HINT: The removal procedure for the RH side is the same as that for the LH side.

65. REMOVE ENGINE ASSEMBLY WITH TRANSAXLE Removal

66. REMOVE FRONT SUSPENSION CROSSMEMBER SUB-ASSEMBLY Removal

67. REMOVE WATER PUMP ASSEMBLY






(a) Remove the 5 bolts and remove the water pump assembly.






(b) Remove the water pump gasket from the timing chain cover.