Part 1

2ZR-FE ENGINE MECHANICAL: CAMSHAFT: REMOVAL

REMOVAL

1. DISCHARGE FUEL SYSTEM PRESSURE Vehicle Damage Warnings
2. REMOVE BATTERY Removal

3. REMOVE BATTERY TRAY
4. REMOVE FRONT WHEELS
5. REMOVE ENGINE UNDER COVER LH
6. REMOVE ENGINE UNDER COVER RH
7. DRAIN ENGINE COOLANT Service and Repair

8. DRAIN ENGINE OIL Replacement

9. REMOVE FRONT WIPER ARM HEAD CAP

10. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY LH

11. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY RH

12. REMOVE HOOD TO COWL TOP SEAL

13. REMOVE COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY

14. REMOVE COWL TOP VENTILATOR LOUVER LH

15. REMOVE FRONT WIPER MOTOR AND LINK

16. REMOVE FRONT AIR SHUTTER SEAL RH Removal

17. REMOVE OUTER COWL TOP PANEL Removal

18. REMOVE AIR CLEANER ASSEMBLY Removal

19. REMOVE AIR CLEANER BRACKET Removal

20. REMOVE BATTERY CARRIER Removal

21. REMOVE NO. 2 CYLINDER HEAD COVER Removal

22. REMOVE FAN AND GENERATOR V BELT Removal

23. REMOVE NO. 2 RADIATOR HOSE Removal

24. DISCONNECT NO. 1 RADIATOR HOSE Removal

25. REMOVE FRONT BUMPER COVER

26. DISCONNECT NO. 1 OIL COOLER OUTLET HOSE (for Automatic Transaxle) Removal

27. DISCONNECT NO. 2 OIL COOLER INLET HOSE (for Automatic Transaxle) Removal

28. REMOVE HOOD LOCK ASSEMBLY Removal

29. REMOVE NO. 1 COOLER COVER Removal

30. REMOVE UPPER RADIATOR SUPPORT ABSORBER

31. REMOVE UPPER RADIATOR SUPPORT SUB-ASSEMBLY Removal

32. REMOVE RADIATOR ASSEMBLY Removal

33. SEPARATE WITH PULLEY COMPRESSOR ASSEMBLY

34. SEPARATE TRANSMISSION CONTROL CABLE ASSEMBLY (for Automatic Transaxle) Removal

35. SEPARATE TRANSMISSION CONTROL CABLE ASSEMBLY (for Manual Transaxle) Removal

36. SEPARATE UNION TO CHECK VALVE HOSE Removal

37. SEPARATE NO. 1 FUEL VAPOR FEED HOSE Removal

38. DISCONNECT ENGINE WIRE Removal

39. DISCONNECT HEATER WATER OUTLET HOSE A (FROM HEATER UNIT) Removal

40. DISCONNECT HEATER WATER INLET HOSE A Removal

41. DISCONNECT FUEL TUBE SUB-ASSEMBLY Removal

42. SEPARATE CLUTCH RELEASE CYLINDER ASSEMBLY (for Manual Transaxle) Removal

43. REMOVE COLUMN HOLE COVER SILENCER SHEET

44. SEPARATE STEERING SLIDING YOKE SUB-ASSEMBLY

45. SEPARATE NO. 1 STEERING COLUMN HOLE COVER SUB-ASSEMBLY

46. REMOVE SHIFT LEVER KNOB SUB-ASSEMBLY (for Manual Transaxle)

47. REMOVE CONSOLE PANEL UPPER

48. REMOVE CONSOLE BOX REAR COVER

49. REMOVE CONSOLE BOX CARPET

50. REMOVE REAR CONSOLE BOX ASSEMBLY

51. REMOVE FRONT CONSOLE BOX

52. REMOVE FRONT FLOOR BRACE CENTER Removal