Part 2

2ZR-FE ENGINE MECHANICAL: CAMSHAFT: INSTALLATION - Continued


58. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY (for Manual Transaxle)

59. INSTALL NO. 1 STEERING COLUMN HOLE COVER SUB-ASSEMBLY

60. INSTALL STEERING SLIDING YOKE SUB-ASSEMBLY

61. INSTALL COLUMN HOLE COVER SILENCER SHEET

62. INSTALL CLUTCH RELEASE CYLINDER ASSEMBLY (for Manual Transaxle) Installation

63. CONNECT FUEL TUBE SUB-ASSEMBLY Installation

64. CONNECT HEATER WATER INLET HOSE A Installation

65. CONNECT HEATER WATER OUTLET HOSE A (FROM HEATER UNIT) Installation

66. CONNECT ENGINE WIRE Installation

67. INSTALL NO. 1 FUEL VAPOR FEED HOSE Installation

68. INSTALL UNION TO CHECK VALVE HOSE Installation

69. INSTALL TRANSMISSION CONTROL CABLE ASSEMBLY (for Automatic Transaxle) Installation

70. INSTALL TRANSMISSION CONTROL CABLE ASSEMBLY (for Manual Transaxle) Installation

71. INSTALL WITH PULLEY COMPRESSOR ASSEMBLY

72. INSTALL RADIATOR ASSEMBLY Installation

73. INSTALL UPPER RADIATOR SUPPORT SUB-ASSEMBLY Installation

74. INSTALL UPPER RADIATOR SUPPORT ABSORBER

75. INSTALL NO. 1 COOLER COVER Installation

76. INSTALL HOOD LOCK ASSEMBLY Installation

77. CONNECT NO. 2 OIL COOLER INLET HOSE (for Automatic Transaxle) Installation

78. CONNECT NO. 1 OIL COOLER OUTLET HOSE (for Automatic Transaxle) Installation

79. INSTALL FRONT BUMPER COVER

80. CONNECT NO. 1 RADIATOR HOSE Installation

81. INSTALL NO. 2 RADIATOR HOSE Installation

82. INSTALL FAN AND GENERATOR V BELT Installation

83. ADJUST FAN AND GENERATOR V BELT Installation

84. INSPECT FAN AND GENERATOR V BELT Installation

85. INSTALL NO. 2 CYLINDER HEAD COVER Installation

86. INSTALL BATTERY CARRIER Installation

87. INSTALL AIR CLEANER BRACKET Installation

88. INSTALL AIR CLEANER ASSEMBLY Installation

89. INSTALL OUTER COWL TOP PANEL Installation

90. INSTALL FRONT AIR SHUTTER SEAL RH Installation

91. INSTALL FRONT WIPER MOTOR AND LINK

92. INSTALL COWL TOP VENTILATOR LOUVER LH

93. INSTALL COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY

94. INSTALL HOOD TO COWL TOP SEAL

95. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY LH

96. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY RH

97. INSTALL FRONT WIPER ARM HEAD CAP

98. INSTALL BATTERY TRAY
99. INSTALL BATTERY Installation

100. ADD ENGINE COOLANT Service and Repair

101. ADD ENGINE OIL Replacement

102. INSPECT FOR FUEL LEAK
103. INSPECT FOR ENGINE OIL LEAK
104. INSPECT FOR EXHAUST GAS LEAK
105. INSPECT FOR ENGINE COOLANT LEAK Testing and Inspection

106. INSTALL ENGINE UNDER COVER RH
107. INSTALL ENGINE UNDER COVER LH
108. INSTALL FRONT WHEELS Installation

109. INSPECT IGNITION TIMING Engine

110. INSPECT ENGINE IDLING SPEED Engine

111. INSPECT CO/HC Engine

112. INSPECT FRONT WHEEL ALIGNMENT

113. INSPECT ABS SENSOR SIGNAL (w/ ABS)

114. INSPECT VSC WARNING (w/ VSC)