Manual Climate Control, MCC

Manual Heating and Ventilation System

Components
No. Name and location
16 Rheostat, instrument lighting; in switch panel between steering wheel and driver's door
22a Main fuse board, dashboard; on side of dashboard by driver's door
35 Switch, ventilation fan; in heating and ventilation control panel
36 Motor, ventilation fan; in centre between bulkhead and partition wall
38 Motor, recirculation flap; on side of heater housing behind glove box
74 Resistor, ventilation fan; under fresh air filter on left-hand side
113 Relay, electrically heated rear window; on main relay board in dashboard
116 Switch, electrically heated rear window; in heating and ventilation control panel
143 Switch, recirculation; in heating and ventilation control panel
154 Lamp, heater controls; in heating and ventilation control panel
169 Switch, A/C; in heating and ventilation control panel
504 Control panel, heating and ventilation; under the radio
541 SID; centre of dashboard
628 Control module, DICE
LHD: above main relay board in dashboard
RHD: behind main relay board in dashboard

Crimped connectors
No. Location
J46 Approx 200 mm from grounding point G33 branching point towards the DICE control module
J59 LHD: Approx 40 mm from branching point grounding point G33 towards main fuse board
RHD: Approx 130 mm from branching point main fuse board towards main fuse board
J64 LHD: Approx 40 mm from rheostat branching point towards MIU
RHD: Approx 110 mm from DICE control module branching point towards bulkhead grommet
J92 LHD:-
RHD: Approx 140 mm from control module DICE branching point towards main fuse board
J94 LHD:-
RHD: Approx 220 mm from radio connector branching point towards connector bracket under left-hand A-pillar
J101 LHD: Approx 170 mm from grounding point G34 branching point towards SID
RHD:-

Crimp connectors
No. Location
JH6 LHD: Approx 180 mm from DICE control module branching point towards brake light switch
RHD: In branching point to main relay board in dashboard

Grounding points
No. Location
G33P Grounding point connector bracket (Power); in compartment below left-hand A-pillar
G34S Grounding point control module bracket (Signal); in compartment below right-hand A-pillar