400 and Up

COMP. COMPONENT NAME:
COMPONENT LOCATION
NO.
403 Solenoid Valve, Swirl Throttle:
On Left MacPherson Strut
404 Solenoid Valve, Exhaust Recirculation:
On Left MacPherson Strut
405 Relay, Reversing Lights:
In Dashboard Main Relay Board
407 Intake Air Temperature Sensor:
petrol: On Induction Manifold
408 Engine Speed Sensor:
On Front Left Of Engine
409 Relay, Auxiliary Heater:
In Engine Bay Main Relay Board
410 Heating Coil, Fuel Filter:
In Fuel Tank Filter
421 Connector, Parking Heater:
By Bulkhead Grommet Under Engine Bay Main Fuse Box
430 Control Module, TRIONIC:
In Cabin On Right Side Below A-pillar
431 Manifold Absolute Pressure Sensor:
Trionic: On Stay Between MacPherson Strut Upper Attachments
432 Relay, Washer Fluid Pump:
In Dashboard Main Relay Board
434a Solenoid, Central Locking System, Filler Cap:
By Filler Cap In Luggage Compartment
435 Microswitch, Central Locking System, Front Passenger Door:
In Passenger Door
439 Solenoid, Selector Lever, SHIFT LOCK:
Under Gear Selector Lever
440 Microswitch, Gear Selector Lever:
Under Gear Selector Lever
444 Data Link Connector, Diagnostics-PC (for Works Use Only):
In Engine Bay
445 Data Link Connector, 16-pin, CARB:
Under Dashboard By Steering Column
446p Relay, Electrically Adjustable Passenger's Seat:
In Seat Under Seat Cushion
451 Glass Breakage Sensor:
In Centre Roof Light Console
456 Antenna, Remote Control, Central Locking System:
Under Defroster In Front Of Door
457 Tilt Sensor:
On Floor Tunnel In Front Of Control Module For Airbag
459 Motor, Vacuum Pump:
In Front Of Washer Fluid Reservoir
460 Relay, Vacuum Pump:
In Engine Bay Main Relay Board
461 Connection, Electronic Highway Toll:
Under Right Dashboard Speaker Grille
463 Antenna Unit, Immobilizer:
By Ignition Switch
493 Relay, Boot Lid Opening:
In Dashboard Main Relay Board
501 Main Fuse Board, Maxi Fuses:
Beside Battery
502 Control Module, TCM:
In Cabin On Right Side Of Bulkhead
504 Heater And Ventilation Controls:
Under The Radio
505 Control Module, Motronic 2.10.3:
In Cabin On Right Side Below A-pillar
506 Switch, WINTER:
Beside Gear Selector Lever
508 Cruise Control Module:
To The Right In Engine Bay Under Windscreen
511 Relay, Electrically Heated Rear Seat:
In Dashboard Main Relay Board
514a Switch, Simultaneous Central Locking:
In Switch Unit Between Seats
514b Switch, Simultaneous Closing Windows:
In Switch Unit Between Seats
517 Starter Relay:
In Dashboard Main Relay Board
519LH Main Relay Board, Rear Seat, Left, Convertible:
Beside Left-hand Speaker In Rear Seat
519RH Main Relay Board, Rear Seat, Right, Convertible:
Beside Right-hand Speaker In Rear Seat
520 SPORT Indicator Lamp:
In Main Instrument Unit
523 CHECK GEARBOX Warning Lamp:
In Main Instrument Unit
531 Solenoid Valves, TCM:
On Underside Of Transmission
532 Speed Sensor, Input Shaft, Gearbox:
On Gearbox
533 Speed Sensor, Output Shaft, Gearbox:
On Gearbox
534 Switch, Kick-down:
Under Accelerator Pedal
535 Temperature Sensor, Transmission Fluid:
On Underside Of Transmission
537 Switch, SPORT:
On Top Of Gear Selector Lever
539 Relay, Starter Motor Interlock, Sensonic:
In Dashboard Main Relay Board
540b Main Instrument Unit:
In Front Of Driver In Dashboard
541 SID:
In Centre Of Dashboard
544 INFO DISPL Information Lamp:
In Main Instrument Unit
545 Warning Lamp, Central Warning:
In Main Instrument Unit
546 WINTER Indicator Lamp:
In Main Instrument Unit
547 Control Module, ABS:
Integrated In Hydraulic Unit Behind Battery
555 Camshaft Position Sensor:
Integrated In Distributor
558 Turbo Pressure Gauge, Main Instrument Unit :
In Main Instrument Unit
559 Temperature Sensor, Engine Oil:
Front Centre On Oil Sump
561LH Microswitch, Left-hand Latch Fitting On Windscreen Frame, Convertible:
In Soft Top Left Latch Fitting In Windscreen Frame
561RH Microswitch, Right-hand Latch Fitting On Windscreen Frame, Convertible:
In Soft Top Right Latch Fitting In Windscreen Frame, Convertible
562LH Microswitch, Tonneau Cover Latch, Left-hand Convertible:
By Tonneau Cover Left Latch
562o Microswitch, Open Tonneau Cover, Convertible:
In Tonneau Cover Hydraulic Cylinder, Right Rear Wing
562RH Microswitch, Tonneau Cover Latch, Right-hand, Convertible:
By Tonneau Cover Right Latch
563d Microswitch, Fifth Bow Down, Convertible:
In Fifth Bow Left Hydraulic Cylinder
563i Microswitch, Fifth Bow In Intermediate Position Convertible:
Above Fifth Bow Left Hydraulic Cylinder
563u Microswitch, Fifth Bow Up, Convertible:
In Fifth Bow Left Hydraulic Cylinder
564LH Microswitch, Soft Top Stowage Bag, Left-hand, Convertible:
On Soft Top Stowage Bag Rear, Lower Left Side
564RH Microswitch, Soft Top Stowage Bag, Right-hand, Convertible:
On Soft Top Stowage Bag Rear, Lower Right Side
565 Control Module, Soft Top Opening, Convertible:
Under Left Rear Seat Speaker
569 Motor, Fifth Bow Latch, Convertible:
Centre Of Soft Top Cover Underside
575a Relay, Electric Window Lift, Front Left:
In Main Relay Board Beside Left Rear Seat Speaker
575b Relay, Electric Window Lift, Front Right:
In Main Relay Board Beside Right Rear Seat Speaker
575c Relay, Electric Window Lift, Rear Left:
In Main Relay Board Beside Left Rear Seat Speaker
575d Relay, Electric Window Lift, Rear Right:
In Main Relay Board Beside Right Rear Seat Speaker
576 Relay, Fifth Bow:
In Main Relay Board Beside Right Rear Seat Speaker
577c Microswitch, Master Cylinder, Soft Top Up:
In Left Master Cylinder
5770 Microswitch, Master Cylinder, Soft Top Down:
In Left Master Cylinder
578LH Microswitch, Fifth Bow Left Side Ready For Locking:
At Fifth Bow Left Latch Fitting On Tonneau Cover
578RH Microswitch, Fifth Bow Right Side Ready For Locking:
At Fifth Bow Right Latch Fitting On Tonneau Cover
579 Relay, Hydraulic Pump, Convertible:
In Main Relay Board Beside Left Rear Seat Speaker
579a Relay, Hydraulic Pump, Pressure, Convertible:
In Hydraulic Unit Behind Rear Seat
579b Relay, Hydraulic Pump, Hitch, Convertible:
in Hydraulic Unit Behind Rear Seat
580 Microswitch, Mixed Air Damper:
On Heater Housing End By Shaft To Mixed Air Damper
581 Solenoid Valve, Heat Exchanger:
On Front Of Heater Housing
585 Pressure Sensor, EVAP:
By Fuel Tank Filler Hose
588 Solenoid Valve, EVAP Shut-off:
In Right Front Wheel Housing
589 Control Module, Trionic OBDII:
In Cabin On Right Side Behind Trim Under A-pillar
590 Accelerometer:
In Engine Bay Behind Left Strut Attachment
592Fa Heated Oxygen Sensor 1, OBDII:
Before Catalytic Converter
592Ra Heated Oxygen Sensor 2, OBDII:
After Catalytic Converter
595A Control Module, EDC 15, Switch A:
In Cabin On Right Side Below A-pillar
595B Control Module, EDC 15, Contact B:
In Cabin On Right Side Below A-pillar
596C Control Module, Glow Plug:
In Engine Bay On Right MacPherson Strut
597 Auxiliary Heater:
In Engine Bay On Right Side Of Bulkhead
598 Diesel Fuel Pump:
On Right Front Of Engine
614P Weight Sensor, Seat Cushion, Passenger Front:
In Passenger Seat Cushion
618 Rheostat, Intermittent Wiper:
In Stalk Switch For Windscreen Wipers
620 Pressure Sensor, A/C:
On Right End Of Condenser
621 Temperature Sensor, Evaporator A/C:
On Evaporator Pipe In Cabin
622 Microswitch, Boot Lock:
In Luggage Compartment Lock In Boot Lid
626 Indicator Lamp, Preheating Diesel:
In Main Instrument Unit
627h Connector, Antenna, Mobile Telephone:
Behind Radio Compartment
628 Control Module, DICE:
LHD: Above Main Relay Board In Dashboard
RHD: Behind Main Relay Board In Dashboard
632 Control Module, TWICE:
Under The Left Seat
633 Switch Unit, Steering Wheel:
On Steering Wheel Rim
633a Switch, Pre-set Radio Station/tape-side/CD-disc:
To The Left On Steering Wheel Rim
633b Switch, Scan Forward:
To The Left On Steering Wheel Rim
633c Switch, Scan Backward:
To The Left On Steering Wheel Rim
633d Switch, Select Radio/tape/CD:
To The Right On Steering Wheel Rim
633e Switch, Increase Volume:
To The Right On Steering Wheel Rim
633f Switch, Decrease Volume:
To The Right On Steering Wheel Rim
634 Microphone, Mobile Telephone:
In Front Roof Console
641 Relay, Preheating Diesel:
In Dashboard Main Relay Board
645a Indicator Lamp, Automatic Transmission Indication, P Position:
In Main Instrument Unit
645b Indicator Lamp, Automatic Transmission Indication, R Position:
In Main Instrument Unit
645c Indicator Lamp, Automatic Transmission Indication, N Position:
In Main Instrument Unit
645d Indicator Lamp, Automatic Transmission Indication, D Position:
In Main Instrument Unit
645e Indicator Lamp, Automatic Transmission Indication, Position 3:
In Main Instrument Unit
645f Indicator Lamp, Automatic Transmission Indication, Position 2:
In Main Instrument Unit
645g Indicator Lamp, Automatic Transmission Indication, Position 1:
In Main Instrument Unit
646 Motor, Hydraulic Pump, Convertible:
In Hydraulic Unit Behind Rear Seat
647a Solenoid Valve, Soft Top:
In Hydraulic Unit Behind Rear Seat
647b Solenoid Valve, Soft Top:
In Hydraulic Unit Behind Rear Seat
648a Solenoid Valve, Soft Top:
In Hydraulic Unit Behind Rear Seat
648b Solenoid Valve, Soft Top:
In Hydraulic Unit Behind Rear Seat