Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 94V074000: Brake Shields Revised
- Recall - Replacement of Front Disc Shields
- Recall 94V110000: Seat Frame Rails Missing Weld
- Recall 94V127000: Seat Rail Lock Does Not Engage
- Recall 94V226000: Seat Falls Back Under a Load
- Recall 95V068000: A/T Does Not Fully Engage in Reverse
- Recall - Throttle Control Lever Bushing Replacement
- Recall 97V046000: Loss of Throttle Control/Binding
- Recall 98V038000: Headlamp Aiming Instruction Omission
- Recall 94V174000: Door Side Impact Beam Weld Faulty
- Recall - Detachable Tow Bar (Trailer Hitch) Replacement
- Recall - Manual Front Seat Rail Spring Rod Replacement
- Customer Interest
- Interior - Uncomfortable Driving Positon
- A/C - Poor Performance
- A/C System - Noises
- Steering/Suspension - Noises From Front of Car
- SID - Low Oil Level Message
- Rear Floor Duct - Rattling Noise
- Cabin Fan - Inoperative
- Power Steering Fluid Reservoir - Leaks
- Timing Chain - Rattles/Chatters
- Engine - Vibration at Idle
- Exhaust - Sulfur Smell
- Body - Door Window Noise/Erratic Operation/Leaks
- Seat Upholstery - Pulling Away From Seats
- Drive Axles - Vibration at Idle
- Clutch Plate - Rattling Noise On Acceleration
- Clutch Pedal - Excessive Freeplay
- Brakes - Vibrations While Braking
- Battery - Discharged
- Battery - Discharging Through Light Switch In Trunk
- Secondary Air Injection Pump - Noise
- Canister Purge Valve - MIL ON/DTC's Set
- Exhaust System - Vibration
- Exhaust - Sulfur/Rotten Egg Smell
- Radio - Interference On the AM Band
- Cylinder Head Gasket - Coolant Leak
- M/T Clutch - Difficult Operation
- Windshield/A Pillar - Windnoise
- Suspension - Front End Vibration
- Upper Center Windshield - Whistling Noise
- Windshield - Fogs Up
- Front Door Window Seal - Comes Loose
- A/T - Whining Noise
- Gear Selector Shaft Seal - Leaks
- Shift Linkage - Binding/Hard Shifting
- Antenna - Fails To Go Up/Down Completely
- Ventilation Fan - Inoperative
- Radio - Interference, Poor Recption On AM
- Dash/Front Seat - Rattling Noise
- M/T - Difficult Reverse Gear Engagement or Jump Out
- M/T - Rattling Noise On Acceleration
- Cooling System - Replace Hose Clamps
- Sunroof - Leaking or Wet Headliner
- Coolant Hoses - Premature Aging
- Body - Stain/Film On Inside Perimeter Of Windshield
- Factory Modifications
- Labor/Parts Updates
- Manual Updates
- Recommended Repairs
- Seals, Gaskets
- Tools, Equipment
- Superceded Bulletins
- 05-06-04-022C - 12/01/06
- 05-06-04-022A - 01/01/06
- 05-06-04-022 - 12/30/05
- 890-18073 - 09/01/99
- 260-1803 - 12/01/97
- 04950566 - 04/01/95
- 01950569 - 01/13/95
- Windshield Wipers - Inadequate Cleaning
- Paint - Colors
- Paint - Color Codes/Cross References
- Fuel System - Top Tier Gasoline Usage (Canada)
- Fuel System - TOP-TIER Gasoline Usage (Canada)
- Pedal Raising Kit - Increase Comfort for Short Drivers
- All Technical Service Bulletins
- TSB 0178291 Dated 01/01/78 is No Longer Available
- Tool - Terminal Repair Kit
- Expander Rivet Extraction Tool
- Tool - Revised Tip for Connector Pin & Socket Removal
- Antilock Brakes - Manual Resistance Reading Corrections
- Vehicle - Service Manual Updates
- Overview
- 0 Technical Data
- 1 Service
- 2:1 Basic Engine B206/B234/B204
- 2:1 Basic Engine B258
- 2:4 Exhaust System. Cooling System. Turbo System
- 2:5 Traction Control System
- 2:7 Motronic 2.10.2 Engine Management System
- 2:7 Motronic 2.8.1 Engine Management System
- 3:1 Electrical System
- 3:2 Electrical System. Wiring Diagrams
- 3:5 Electrical System Instruments
- 4:1 Manual Gearbox
- 4:2 Automatic Transmission
- 5 Brakes
- 6 Front Assembly and Steering
- 7 Suspension and Wheels
- 8:1 Body, Body Repairs
- 8:2 Interior Equipment
- 8:6 Airbag
- Interior - Uncomfortable Driving Positon
- Recall 94V074000: Brake Shields Revised
- A/C - Poor Performance
- Electronic Antifrost Thermostat - Installation
- A/C System - R12 to R134a Conversion/Retrofit
- A/C System - Noises
- Front Assembly - Technical Data Corrections
- Steering/Suspension - Noises From Front of Car
- M/T - Adjustment of Output Shaft Bearing Tension
- Engine - Availability of Complete Assemblies
- Cylinder Head Bolt - Tightening Torque
- Engine - Revisions to Service Manuals
- Recall - Replacement of Front Disc Shields
- Brake Pads - Approved Designs/Applications
- SID - Low Oil Level Message
- Rear Floor Duct - Rattling Noise
- Cabin Fan - Inoperative
- Power Steering Gear - Microfiche Correction
- Power Steering Fluid Reservoir - Leaks
- Power Steering Fluid - Specification Change
- Crankshaft Pulley Bolt - Socket
- Timing Chain - Rattles/Chatters
- Engine Block - Pitting Correction
- Engine Block - Deck Surface Pitting
- Campaign - Water Pump Replacement
- Engine - Vibration at Idle
- Special Tools - Availability
- Exhaust - Sulfur Smell
- Rims/Tires - Vibration Diagnosis
- Radial Tire - Repair
- Body - Door Window Noise/Erratic Operation/Leaks
- Seat Upholstery - Pulling Away From Seats
- Recall 94V110000: Seat Frame Rails Missing Weld
- Recall 94V127000: Seat Rail Lock Does Not Engage
- Recall 94V226000: Seat Falls Back Under a Load
- Special Tools - Transmission and Headliner Repair
- Drive Axles - Vibration at Idle
- Outboard Drive Shaft CV Joint - Normal Noises
- Drive Shaft Seal - Special Tool
- Clutch Plate - Rattling Noise On Acceleration
- Recall 95V068000: A/T Does Not Fully Engage in Reverse
- Clutch Pedal - Excessive Freeplay
- Brakes - Vibrations While Braking
- Brake Fluid Reservoir Cap - Proper Fit
- Battery - Discharged
- Battery - Discharging Through Light Switch In Trunk
- Special Tool - Battery Tester 311
- Ignition Switch - Contacts Binding
- Ignition Discharge Module - New Special Tool
- Ignition Discharge Module - Pre-Replacement Check
- Recall - Throttle Control Lever Bushing Replacement
- Recall 97V046000: Loss of Throttle Control/Binding
- Secondary Air Injection Pump - Noise
- Canister Purge Valve - MIL ON/DTC's Set
- Exhaust System - Vibration
- Exhaust - Sulfur/Rotten Egg Smell
- Trunk Light/Heated Rear Window Switch - Replacement
- Door Mirrors - Adapting for Tall Drivers
- Radio - Interference On the AM Band
- Mobile Telephones - Factory Connectors
- Mobile Telephones - Dash Connector
- Seat Belt Button - Replacing
- Engine Oil Filters/Drain Plug Gaskets - Part Numbers
- Brake Rotor - Measuring Fixture
- Recall 98V038000: Headlamp Aiming Instruction Omission
- Cylinder Head Gasket - Coolant Leak
- M/T Clutch - Difficult Operation
- Parking Brake - 2 Cable System Adjustment
- ABS System - Diagnostic Procedures
- Windshield/A Pillar - Windnoise
- SRS - Wiring Harness Installation
- SRS System - Diagnosis
- Supplementary Restraint System - 10 Year Inspection
- Restraints - Pyrotechnic Device Component Usage
- Evaporative System - Leak/Pressure Testing
- Trouble Codes - (Errant) Fault May Not Exist
- ISAT Scan Tool Diagnostics Set - Changes
- Essential Special Tools - New Releases
- Tools - ISAT TECH 2
- ISAT Scan Tool - Repair Procedure
- Suspension - Front End Vibration
- Recall 94V174000: Door Side Impact Beam Weld Faulty
- Upper Center Windshield - Whistling Noise
- Windshield - Fogs Up
- Front Door Window Seal - Comes Loose
- Windshield Washer Nozzles - Adjustable
- A/T - Torque Specification Modification
- A/T - Whining Noise
- A/T - Service Manual Correction
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Gear Selector Shaft Seal - Leaks
- M/T - Gear Selector Shaft Oil Seal Leaks
- Shift Linkage - Binding/Hard Shifting
- Antenna - Fails To Go Up/Down Completely
- Campaign - Poly-V Belt Replacement
- Gear Position Sensor/Selector Cable - Adjustment
- Gear Position Sensor - Special Tool
- Coolant Temperature Sensor - Revision
- Ventilation Fan - Inoperative
- Tool - Tech 2 Compatability W/Operating Systems
- Steering/Front Assembly - Manual Updates
- Wheel Alignment, Rear - Service Manual Corrections
- Wiring - Terminal Repair Kit Contents
- Wiring - Harness Repair Kit
- Electrical Connector - Moisture Sealing Kit
- Electrical - Wiring Harness Repair Kit
- Convertible Top - Leakage
- Convertible Top - Hydraulic Fluid Level
- Radio - Interference, Poor Recption On AM
- Dash/Front Seat - Rattling Noise
- Windows/Glass - New Installation Sealant
- Body - Door/Side Window Adjustment Procedure
- Paint Codes - Applications and Cross Reference
- Paint Colors - Cross Reference & Information
- Subframe - Repairing Damaged Threads
- Turbo Air Bypass Valve - Updated
- Trailer Hitch Coupler - Insufficient Lubrication
- Trailer Hitch - Installation
- Recall - Detachable Tow Bar (Trailer Hitch) Replacement
- Recall - Manual Front Seat Rail Spring Rod Replacement
- M/T - Difficult Reverse Gear Engagement or Jump Out
- M/T - Rattling Noise On Acceleration
- Cooling System - Replace Hose Clamps
- Sunroof - Leaking or Wet Headliner
- Coolant Hoses - Premature Aging
- Maintenance Schedule
- Vehicle - Maintenance Schedules
- Vehicle - Maintenance/Service Interval Charts
- Vehicle - Service/Maintenance Charts
- CD Changer - Installing
- CD Changer - Manually Releasing a CD
- Frame - Lifting and Attachment Points
- Child Tether Anchorage - Availability
- A/C - Compressor Oil Recommendations
- Seat Back - Upholstery Replacement
- Fuel System - TOP TIER Detergent Gasoline
- Body - Stain/Film On Inside Perimeter Of Windshield
- Wheels - Chrome Wheel Staining/Pitting/Corrosion