Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Brakes - Brembo(R) Caliper Paint Peeling Prevention
- A/C - Poor Heater Performance in Extreme Cold
- Body - Clear Coat Flaking Off of Spoiler
- M/T - Rattling Noise Idling in Neutral
- Audio System - Speaker Static/Buzzing/Inoperative
- Suspension - Squeak From Rear of Vehicle While Driving
- Fuel/Emissions - Sulfur Odor From Exhaust
- Body - Creaking Noise from Windshield/A-Pillar Area
- Cooling System - Upper/Lower Radiator Hose Collapsed
- A/C - Temperature Knob Hard to Turn
- Audio System - Static/Popping/Poor Sound/Distortion
- M/T - Grinds on 2nd to 3rd/4th to 5th Gear Shifts
- Engine Controls - MIL ON/DTC's P0300 or P0301-P0304 Set
- Engine Controls - Hard/No Start/DTC P0335 or P0340 Set
- Superceded Bulletins
- 04-35-005 - 12/01/04
- 04-13-007 - 07/01/04
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- Lighting - Moisture In Headlamps
- Body - Color Codes
- Antitheft - Updated Service Information
- Keyless Entry System - Description/Operation
- Keyless Entry - ID Mode Canceling Conditions Revision
- M/T - Grinding Noise On 2-3 or 4-5 Shift
- Engine Controls - MIL ON/DTC P0300 Set
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Restraints - SRS Component Disposal Information
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Brakes - Brembo(R) Caliper Paint Peeling Prevention
- Vehicle - Load Capacity Reduction Label Information
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Brakes - Cleaning Brembo Brake Calipers
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- A/C - Poor Heater Performance in Extreme Cold
- Engine - Revised Valve Guide/Valve Stem Specifications
- Engine - Timing Belt Service Procedure Revision
- Engine - Cylinder Head Height Specification Revision
- Engine - Valve Lash Adjuster Cleaning Procedure
- Engine - Valve Lifter Noise Diagnosis
- Cooling System - Water Pump Failure
- Tires - Tire Pressure Specifications
- Body - Clear Coat Flaking Off of Spoiler
- Vehicle - Aftermarket Accessories Precautions
- M/T - Rattling Noise Idling in Neutral
- M/T - Clutch Release Bearing Installation
- Engine Controls - PCM Reprogramming Procedure
- Brake - Bleeding Procedures
- Battery - Application Guide/Cold Cranking Amp Specs.
- Battery - Load Test Rate Chart Revision
- Alternator - FR Terminal Voltage Revision
- Engine Controls - PCM Reflash for DTC P0300
- Engine Controls - DTC P0300 Resets After Reprogramming
- Recall - PCM Update for Warm-Up Cat. Converter Melt Down
- Engine - Poor High RPM Acceleration
- Audio System - Speaker Static/Buzzing/Inoperative
- Suspension - Squeak From Rear of Vehicle While Driving
- Suspension - Revised Rear Lower Arm Bushing Replacement
- Body - Revised Body Repair Procedures
- Body - Noise Diagnosis
- Recall - Air Bag Warning Label Installation
- Antitheft System - Service Information Update
- Fuel/Emissions - Sulfur Odor From Exhaust
- Engine Controls/Emissions - OBDII Drive Cycle Revisions
- Engine Controls - DTC P0441
- Fuel System - MIL ON with DTC P0171/174
- Fuel System/Engine Controls - Driveability Concerns
- Fuel System - EVAP DTC's & Check Engine Light
- Engine Controls - DTC P0300 Cold Engine Misfire
- Fuel System - DTC P0181 Update
- Engine Controls - Freeze Frame Data For DTC's
- Body - Creaking Noise from Windshield/A-Pillar Area
- Body - A Pillar Rattling/Clicking Noise
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- Cooling System - Radiator Hose Collapsed
- Cooling System - Collapsed Upper Radiator Hose
- Cooling System - Upper/Lower Radiator Hose Collapsed
- A/T - New End-Play and Preload Measurement
- A/C - Inoperative/A/C Light Blinks
- A/C - Temperature Knob Hard to Turn
- A/T - No Overdrive/Shift Delay
- Instruments - Speedometer is Inoperative
- Cruise Control - Diagnostics Revisions
- Tires/Wheels - Tire Chain Usage
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Keyless Entry - Description/Operation
- Keyless Entry - ID Mode Canceling Conditions Update
- Keyless Entry - Answerback Switching Procedures Revision
- Body - Wind Buffeting
- Audio System - Static/Popping/Poor Sound/Distortion
- Paint - Paint Codes
- A/C - Compressor Pressure Relief Valve Service
- M/T - Grinds on 2nd to 3rd/4th to 5th Gear Shifts
- A/C - Cabin Filter Service Tip
- Engine - Pinging Condition
- Interior - Recaro Seatback Bolster Cover Breakage
- M/T, Fuel - Accelerator/Clutch Pedal Stopper Revision
- Engine Controls - MIL ON/DTC's P0300 or P0301-P0304 Set
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- Body - Corrected Sunroof Initialization Procedures
- Engine Controls - Hard/No Start/DTC P0335 or P0340 Set
- Interior - Rev. Front Door Interior Trim Core & Tube R&I
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Steering - Revised Tie Rod Free Play Inspection
- Body/Frame - Corrosion Inhibitor Information
- Suspension - Corrected Front Strut Mounting Bolt Torque
- Engine - Revised Timing Belt Tensioner Tool Information
- Brakes - Revised ABS Hydraulic Unit Torque Specification
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- M/T - M/T Overhaul Recommendation
- Engine - Fouled Spark Plugs Causing Misfire
- Powertrain, Antitheft - ECU & PCM Replacement
- Lighting - Headlamp Moisture Information
- Powertrain - Freeze Frame Data & MFI Related DTC's
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine - Lead Free Crankshaft Bearing Info. Revision
- Engine Controls - Revised Misfire DTC Information
- M/T - Revised Shift Cable Installation Procedure
- Body - Revised Door Adjustment Procedure
- Restraints - Revised SRS ECU Removal and Installation