Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 98V069000: Transfer Case Lubrication Problem
- Recall 98V069001: Transfer Case May Lock-up
- Recall - Lower Ball Joint/Control Arm Inspection
- Recall - Transfer Case Inspection and Repair
- Recall 98V045001: Dash Interferes with Thottle Cable
- Recall - Dash Panel Pad Modification
- Recall 98V045001: Dash Interferes with Throttle
- Recall 98V045000: Dash Interferes with Throttle Cable
- Recall 98V069000: Insufficient Transfer Case Lubrication
- Customer Interest
- Engine - Valve Noise at Start-up
- Spark Plug - Fouling
- A/C - Musty/Moldy Odors In Passenger Compartment
- Rear Suspension - Squeak/Rubbing Noise
- Door Glass - Creaking/Popping Noise
- A/T - Poor Shift Quality
- Audio - Malfunction/Failure
- Audio System - Speaker Static/Buzzing/Inoperative
- Fuel/Emissions - Sulfur Odor From Exhaust
- Front Windshield Washer - Nozzle Leakage
- Generator Drive Belt - Noise
- Radio - Poor Reception
- Window - Chemical Film Build-Up/Fogging
- Audio System - Static/Popping/Poor Sound/Distortion
- Suspension - Front Creaking/Poping/Squeaking Noises
- Brakes - Judder (vibration) Diagnosis and Repair
- Sunroof - Sunshade Material Delamination
- Recommended Repairs
- Superceded Bulletins
- SR-98-002R - 05/01/98
- 99-002 - 06/01/99
- 98-34-001 - 05/01/98
- 98-23-002 - 04/01/98
- 97-54-015 - 12/01/97
- 91-52B-002 - 02/01/97
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- 01-00-011 - 07/01/01
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Audio System - Diagnosis
- Remote Keyless Entry - Service Information
- Recall - Lower Ball Joint Replacement
- Scan Tool - Warranty Coverage/Repair Return Procedures
- OBD II Monitor Readiness - Drive Cycle Procedures
- Engine - Testing for Excessive Oil Consumption
- Engine - Oil Economy Test/Consumption Diagnosis
- Cylinder Block - Heater Installation Procedure
- Engine Block Heater - Application and Installation
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- VIN - Decoder Chart
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Recall 98V069000: Transfer Case Lubrication Problem
- Recall 98V069001: Transfer Case May Lock-up
- Engine - Valve Noise at Start-up
- Tool - Battery/Starting/Charging System Analyzer
- Spark Plug - Fouling
- A/C Magnetic Clutch - Corrected Service Procedures
- A/C - Musty/Moldy Odors In Passenger Compartment
- Crankshaft Bearing - Procedure Correction
- Engine - Valve Lash Adjuster Cleaning Procedure
- Piston Pin - Installation Tool Instructions
- Engine - Replacement Piston Selection
- Recall - Lower Ball Joint/Control Arm Inspection
- Rear Suspension - Squeak/Rubbing Noise
- Wheel - Balancing Accuracy Tips
- Snow Tires - List of Recommendations
- Tires - Chain Use Tables
- Tires - Goodyear(R) Product Service Locations
- Door Glass - Creaking/Popping Noise
- Interior - Wind Noise Diagnosis
- Recall - Transfer Case Inspection and Repair
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- Engine Controls - PCM Reprogramming Procedure
- Battery - Application Guide/Cold Cranking Amp Specs.
- A/T - Poor Shift Quality
- Recall 98V045001: Dash Interferes with Thottle Cable
- Recall - Dash Panel Pad Modification
- Rear Window Defogger Grid - Repair
- Power Seat - Motor Replacement Procedure
- Audio - Malfunction/Failure
- Audio System - Speaker Static/Buzzing/Inoperative
- Air Bag - Minimizing Deployment Risk
- SRS - Diagnostic Trouble Code (DTC) Erasure
- Engine - Block Heater Update
- Stop Lights - Switch Adjustment Procedure Revised
- Engine - Revised Cylinder Head Gasket Design
- Antilock Brake System - Diagnosis
- Payload/Gross Vehicle Weight Rating Information
- Synthetic Resin Parts - Heat Resistance Specifications
- Body - Noise Diagnosis
- Emissions - OBDII Readiness Code Information
- Emissions - OBD-II I/M Program Summary
- Fuel/Emissions - Sulfur Odor From Exhaust
- Engine Controls - DTC P0441
- Tools - Enhanced Diagnostic Testing & Feature Software
- Scan Tool - Multi-Use Tester II Warranty Coverage
- Engine Controls - SCAN Tool Display Term Changes
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Front Windshield Washer - Nozzle Leakage
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- A/T End Clutch - Improved
- A/T - Remanufacturing Program.
- A/T, Remanufactured - Program Update
- A/T - Recommended Maintenance
- A/T - New End-Play and Preload Measurement
- M/T - Recommended Maintainence
- Audio System - CD Player Functional Problems
- Generator Drive Belt - Noise
- Recall 98V045001: Dash Interferes with Throttle
- Engine - Oil Economy Test
- Engine - Oil Consumption/Oil Economy Test
- Fuel - Poor Driveability Using Premium
- Recall 98V045000: Dash Interferes with Throttle Cable
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Remote Keyless Entry - Update
- Radio - Poor Reception
- Automatic Transaxle - Shift Characteristics of F4A
- Interior - Buzz, Squeak, and Rattle Kit
- Window - Chemical Film Build-Up/Fogging
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Audio System - Static/Popping/Poor Sound/Distortion
- Paint - Exterior Color Code & Cross Reference
- A/C Compressor Revolution Sensor - Resistance Revision
- ABS - Diagnostic Connector Wired Incorrectly
- Recall 98V069000: Insufficient Transfer Case Lubrication
- A/C - Compressor Pressure Relief Valve Service
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C Refrigerant - Service Information
- Overview
- Refrigerants and Their Availability
- System Differences
- Refrigerant Differences
- Lubricant Differences
- Retrofitting Systems
- Recovery and Recycling of Refrigerants
- Storing Recycled Refrigerant
- Transferring Recycled Refrigerant
- System Flushing
- Typical Cause of A/C System Contamination
- Mixing Refrigerants
- Contaminated Service Equipment
- Disposing of Contaminated Refrigerant
- Suspension - Front Creaking/Poping/Squeaking Noises
- Brakes - Judder (vibration) Diagnosis and Repair
- Engine - Pinging Condition
- Sunroof - Sunshade Material Delamination
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine - Lead Free Crankshaft Bearing Info. Revision
- Engine Controls - Revised Misfire DTC Information
- Restraints - Revised SRS ECU Removal and Installation