Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 00V421001: Lower Ball Joint Separation
- Recall 99V066001: Damaged Lower Ball Joint Boots
- Recall - Lower Ball Joint/Control Arm Inspection
- Recall - Transfer Case Inspection and Repair
- Recall - Fuel Tank Leak
- Recall 96V158000: Fuel Pump/Fuel Gauge Unit Gasket Leak
- Recall 96V158001: Fuel Tank Unit Gasket Leak
- Recall 94V149002: ABS Hydraulic Unit Attachment
- Recall - ABS Hydraulic Unit Support Cracks
- Recall 94V149000: ABS Hydraulic Unit Attachment Point
- Recall 98V069000: Insufficient Transfer Case Lubrication
- Customer Interest
- Steering - Drift Diagnosis And Correction.
- Engine - Valve Noise at Start-up
- Engine - Erratic Idle/Low Performance/MIL ON
- Spark Plug - Fouling
- Engine - Intermittent Misfire
- Engine - Misfire/MIL ON/DTC's Set
- Rear Shock Absorber - Thumping/Knocking Noise
- Rear Suspension - Squeak/Rubbing Noise
- Door Glass - Creaking/Popping Noise
- Headliner - Front Edge Sags
- Brakes - ABS Lamp ON/Multiple DTC's Set
- PCM - Poor Driveability/DTC's Set
- A/T - Poor Shift Quality/Shudder
- Power Seat - Moves After Switch Is Released
- Audio System - Speaker Static/Buzzing/Inoperative
- Brakes - Grinding/Scraping Noise/Premature Wear
- Electrical - No Start/Hard Start/MIL ON/AC Fan Inop.
- Secondary Air Injection System - DTC 51 Set
- Rear Speaker - Buzz or Rattle
- Door Window - Popping/Rattling/Squeaking
- Door Glass - Wind Noise/Water Leaks
- Sunroof/Sunshade - Inoperative or Noisy
- Sunroof - Inoperative/Remains Open
- Windshield - Wind Noise
- Front Windshield Washer - Nozzle Leakage
- A/T - F4AC1 Limp-In Mode/DTC's Set
- A/T - F4AC1 Clicking Noise
- Antitheft - Random Alarm Activation
- Turbocharger Oil Outlet Pipe - Leaks
- Radio - Poor Reception
- Window - Chemical Film Build-Up/Fogging
- Paint - Spotting/Whitening
- Retractable Hardtop - Downstop Interference
- Recall - ABS Hydraulic Unit Support Cracks
- Right Side A Pillar - Water Leak
- Suspension - Front Creaking/Poping/Squeaking Noises
- Sunroof - Difficult Sunshade Operation
- Brakes - Judder (vibration) Diagnosis and Repair
- Recommended Repairs
- Superceded Bulletins
- SR-98-002R - 05/01/98
- 99-002 - 06/01/99
- 98-34-001 - 05/01/98
- 96-11-002 - 03/01/96
- 94-35-001 - 09/01/94
- 91-52B-002 - 02/01/97
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- Front Windshield Washer Nozzle - Leakage
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Audio System - Diagnosis
- Remote Keyless Entry - Service Information
- Recall - Lower Lateral Arm Ball Joint Boot
- Recall - Lower Ball Joint Replacement
- PCM - Replacement For DTC 111 & 126 And Driveability
- Cylinder Block - Heater Installation Procedure
- Engine Block Heater - Application and Installation
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- VIN - Decoder
- VIN - Decoding
- Electrical Circuit - Diagram Corrections
- A/C - System Leak Checking
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Steering - Drift Diagnosis And Correction.
- Engine - Valve Noise at Start-up
- VIN - Service Manual Revision
- Engine - Erratic Idle/Low Performance/MIL ON
- Spark Plug - Gap Specifications
- Spark Plug - Fouling
- Engine - Intermittent Misfire
- Engine - Misfire/MIL ON/DTC's Set
- A/C Magnetic Clutch - Corrected Service Procedures
- Engine - Head & Main Bolt, Rod Nut Torque Revision
- Engine - Revised Nut & Bolt Tightening Specifications
- Crankshaft Oil Seal - Removal/Installation Revision
- Engine - Valve Lash Adjuster Cleaning Procedure
- Valve Lash Adjuster Noise - Troubleshooting Procedures
- Piston Pin - Installation Tool Instructions
- Engine - Piston Ring Installation Corrections
- Timing Belt Auto Tensioner - Testing
- Lateral Lower Arm Ball Joint - Torque Revision
- Recall 00V421001: Lower Ball Joint Separation
- Recall 99V066001: Damaged Lower Ball Joint Boots
- Recall - Lower Ball Joint/Control Arm Inspection
- Rear Shock Absorber - Thumping/Knocking Noise
- Rear Suspension - Squeak/Rubbing Noise
- Wheel - Balancing Accuracy Tips
- Revised Wheel Nut Tightening Torque - Manual Revision
- Door Glass - Creaking/Popping Noise
- Interior - Wind Noise Diagnosis
- Sunroof - Service Procedures Revision
- Headliner - Front Edge Sags
- Recall - Transfer Case Inspection and Repair
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- Engine Controls - PCM Reprogramming Procedure
- CV Joint Boot - Replacement Tool/Installation
- Brakes - Service Information Revisions
- Brakes - ABS Lamp ON/Multiple DTC's Set
- Brake Booster - Specification Correction
- Brake Booster - Push Rod Adjustment
- Brake Booster Push Rod - Clearance Revision
- Brake Booster - Specifications Change
- Battery - Application Guide/Cold Cranking Amp Specs.
- Generator Stator - Removal Procedure Revision
- PCM - Poor Driveability/DTC's Set
- A/T - Poor Shift Quality/Shudder
- Recall - Fuel Tank Leak
- Recall 96V158000: Fuel Pump/Fuel Gauge Unit Gasket Leak
- Turbocharger Oil Pipes - Service Manual Revision
- Power WIndow Switch - Continuity Check Chart
- Rear Window Defogger Grid - Repair
- Power Seat - Moves After Switch Is Released
- Power Seat - Motor Replacement Procedure
- Audio System - Speaker Static/Buzzing/Inoperative
- Air Bag - Minimizing Deployment Risk
- SRS Air Bag Troubleshooting - Revision
- SRS - Trouble Shooting, Front Impact Sensor Inspection
- SRS - Diagnostic Trouble Code (DTC) Erasure
- Engine - Block Heater Update
- Fuel Gauge Unit - Inspection Procedures Revision
- Fuel Guage Tank Unit - Installation Procedure
- Headlights - Aiming Procedures Revised
- Brakes - Grinding/Scraping Noise/Premature Wear
- Engine - Revised Cylinder Head Gasket Design
- ABS - Circuit Diagram Correction
- Antilock Brake System - Diagnosis
- ABS - Data List Reference/Actuator Test Reference Table
- Payload/Gross Vehicle Weight Rating Information
- Synthetic Resin Parts - Heat Resistance Specifications
- Body - Noise Diagnosis
- SRS Circuit Diagram - Corrections
- SRS Warning Lamp Bulbs - Service Manual Correction
- Engine Controls - DTC P0441
- Electrical - No Start/Hard Start/MIL ON/AC Fan Inop.
- Wiring Harness - Connector Compatibility
- OBD-II - Drive Cycle Information Addition
- Tools - Enhanced Diagnostic Testing & Feature Software
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Secondary Air Injection System - DTC 51 Set
- Rear Speaker - Buzz or Rattle
- Door Window - Popping/Rattling/Squeaking
- Door Glass - Wind Noise/Water Leaks
- Sunroof Drive Motor Insert Clip - Precautions
- Sunroof/Sunshade - Inoperative or Noisy
- Sunroof - Inoperative/Remains Open
- Windshield - Wind Noise
- Front Windshield Washer - Nozzle Leakage
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- Automatic Transaxle - Improved Rear Clutch
- A/T - F4AC1 Limp-In Mode/DTC's Set
- A/T - F4AC1 Clicking Noise
- A/T - Remanufacturing Program.
- A/T - F4AC1 Troubleshooting Revisions
- A/T, Remanufactured - Program Update
- A/T - Recommended Maintenance
- Transmission - Identification Codes
- A/T - New End-Play and Preload Measurement
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Third Gear Limp-in Condition
- A/T - KM175 Delayed Forward Engagement
- A/T - KM175 Harsh Downshifts
- A/T - KM175 Series 1-2 Bind Up
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - F5MC1 Related Service Information Revision
- M/T - Recommended Maintainence
- Antitheft - Random Alarm Activation
- Heater Control Panel - Revised Removal Procedures...
- Turbocharger Oil Outlet Pipe - Leaks
- Idle Switch Inspection - Service Manual Revision
- Engine - Proper Camshaft Sprocket Installation
- Engine - Oil Economy Test
- Engine - Oil Consumption/Oil Economy Test
- Circuit Diagram Configuration - Corrections
- Chemicals - Fuel Injector Cleaner Feels 1/2 Full
- Fuel - Poor Driveability Using Premium
- Auto-Cruise Control System Circuit Fuse - Correction
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Front Drive Shaft - Revised Repair Kit Information
- Keyless Entry System - Service Manual Revision
- Remote Keyless Entry - Update
- Remote Keyless Entry System - Information Corrections
- Radio - Poor Reception
- Antenna - Inspection and Caution Revision
- A/T - Circuit Diagram Revision
- Automatic Transaxle - Shift Characteristics of F4A
- Interior Trim - Improve Fit On Liftgate
- Interior - Buzz, Squeak, and Rattle Kit
- Window - Chemical Film Build-Up/Fogging
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Paint - Exterior Color Code & Cross Reference
- Paint - Damage Identification and Repair
- Paint - Spotting/Whitening
- Retractable Hardtop - Downstop Interference
- A/C Compressor Revolution Sensor - Resistance Revision
- Recall 96V158001: Fuel Tank Unit Gasket Leak
- A/T - F4AC1 Valve Body Installation Revision
- Recall 94V149002: ABS Hydraulic Unit Attachment
- Recall - ABS Hydraulic Unit Support Cracks
- Recall 94V149000: ABS Hydraulic Unit Attachment Point
- Recall 98V069000: Insufficient Transfer Case Lubrication
- A/C - Compressor Pressure Relief Valve Service
- Power Seat Limit Switch - Service Manual Revision
- Front Axle - Drive Shaft Removal Procedure
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C Refrigerant - Service Information
- Overview
- Refrigerants and Their Availability
- System Differences
- Refrigerant Differences
- Lubricant Differences
- Retrofitting Systems
- Recovery and Recycling of Refrigerants
- Storing Recycled Refrigerant
- Transferring Recycled Refrigerant
- System Flushing
- Typical Cause of A/C System Contamination
- Mixing Refrigerants
- Contaminated Service Equipment
- Disposing of Contaminated Refrigerant
- Right Side A Pillar - Water Leak
- M/T Shift Lever - Operational Inspection Revision
- Homelink Universal Transmitter System - Features
- Rear Disc Brake/Proportioning Valve - Revision
- Suspension - Front Creaking/Poping/Squeaking Noises
- Sunroof - Difficult Sunshade Operation
- Brakes - Judder (vibration) Diagnosis and Repair
- Hardtop - Performance Characteristics
- Engine - Pinging Condition
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine - Lead Free Crankshaft Bearing Info. Revision
- Engine Controls - Revised Misfire DTC Information
- Restraints - Revised SRS ECU Removal and Installation