Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Campaign - Retractable Hardtop Upgrade
- Overview
- Affected Vehicles
- Description
- Required Service Operations
- 3000GT Spyder Upgrade Summary
- Upgrade Program Duration
- Upgrade Scheduling Sequence
- Upgrade Appointment Preparation
- Other Considerations
- Rental Vehicle Arrangements
- Test Drive Procedure
- Warranty Information
- Attachment 1 - Owner Letter
- Owner Letter
- Campaign - Retractable Hardtop Upgrade
- Safety
- Generals
- Customer Interest
- Recommended Repairs
- Superceded Bulletins
- 96-11-002 - 03/01/96
- 91-52B-002 - 02/01/97
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Retractable Hardtop - Repair
- Audio System - Diagnosis
- Remote Keyless Entry - Service Information
- Cylinder Block - Heater Installation Procedure
- Engine Block Heater - Application and Installation
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- VIN - Decoder
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Engine - Valve Noise at Start-up
- Spark Plug - Fouling
- Rear Hub - Additional Removal Information
- Engine - Head & Main Bolt, Rod Nut Torque Revision
- Engine - Revised Nut & Bolt Tightening Specifications
- Engine - Valve Lash Adjuster Cleaning Procedure
- Valve Lash Adjuster Noise - Troubleshooting Procedures
- Piston Pin - Installation Tool Instructions
- Rear Shock Absorber Tightening Torque - Manual Revision
- Wheel - Balancing Accuracy Tips
- Interior - Wind Noise Diagnosis
- Interior - Water Leak Test Procedure
- Recall 98V020000: Sunroof Control Defect
- Recall - Transfer Case Leakage
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- Engine Controls - PCM Reprogramming Procedure
- EGR & EVAP Purge Solenoid - Locator Revisions
- CV Joint Boot - Replacement Tool/Installation
- Rear Wheel ABS Speed Sensor - Revised Resistance Value
- Brake Booster - Push Rod Adjustment
- Battery - Application Guide/Cold Cranking Amp Specs.
- Generator Stator - Removal Procedure Revision
- Starter Relay - Terminal Number Revision
- Throttle Body - Overhaul Procedure Revision
- Rear Window Defogger Grid - Repair
- Audio System - Speaker Static/Buzzing/Inoperative
- Air Bag - Minimizing Deployment Risk
- SRS Air Bag Troubleshooting - Revision
- SRS Cautions and Warnings - Revision
- SRS - Diagnostic Trouble Code (DTC) Erasure
- Brakes - Disc Run-Out Specification Limits
- Engine - Block Heater Update
- Engine - 6G7 Bearing Identification Marks
- Headlamps - Revised Adjusting Procedures
- Antilock Brake System - Diagnosis
- Payload/Gross Vehicle Weight Rating Information
- Synthetic Resin Parts - Heat Resistance Specifications
- Body - Noise Diagnosis
- Vacuum Hose Diagram - Correction
- Engine Controls - DTC P0441
- Wiring Harness - Connector Compatibility
- Tools - Enhanced Diagnostic Testing & Feature Software
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Horn Button - Pops Out Of Steering Wheel
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- A/T - Remanufacturing Program.
- A/T, Remanufactured - Program Update
- A/T - Recommended Maintenance
- Transmission - Identification Codes
- A/T - New End-Play and Preload Measurement
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Recommended Maintainence
- Idle Switch Inspection - Service Manual Revision
- Engine - Oil Economy Test
- Engine - Oil Consumption/Oil Economy Test
- Junction Block Relays - Location Corrections
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Remote Keyless Entry - Update
- Automatic Transaxle - Shift Characteristics of F4A
- Interior - Buzz, Squeak, and Rattle Kit
- Aero Parts Damage Prevention - Manual Revision
- Window - Chemical Film Build-Up/Fogging
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Paint - Exterior Color Code & Cross Reference
- Paint - Damage Identification and Repair
- Cylinder Head Bolt - Corrected Tightening Procedures
- A/C - Compressor Pressure Relief Valve Service
- Fuel Tank - Drain Plug Washer and Torque Revision
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C Refrigerant - Service Information
- Overview
- Refrigerants and Their Availability
- System Differences
- Refrigerant Differences
- Lubricant Differences
- Retrofitting Systems
- Recovery and Recycling of Refrigerants
- Storing Recycled Refrigerant
- Transferring Recycled Refrigerant
- System Flushing
- Typical Cause of A/C System Contamination
- Mixing Refrigerants
- Contaminated Service Equipment
- Disposing of Contaminated Refrigerant
- M/T Shift Lever - Operational Inspection Revision
- Garage Door Transmitter - Reprogramming Procedure
- Brakes - Judder (vibration) Diagnosis and Repair
- Campaign - Retractable Hardtop Upgrade
- Overview
- Affected Vehicles
- Description
- Required Service Operations
- 3000GT Spyder Upgrade Summary
- Upgrade Program Duration
- Upgrade Scheduling Sequence
- Upgrade Appointment Preparation
- Other Considerations
- Rental Vehicle Arrangements
- Test Drive Procedure
- Warranty Information
- Attachment 1 - Owner Letter
- Owner Letter
- Retractable Hardtop - Revised Repair Policies/Procedures
- Hard Top - Flipper Door Spring Replacement
- Hard Top - Operational Characteristics
- Engine - Pinging Condition
- Antenna Motor Control Unit - Inspection Revision
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine Controls - Revised Misfire DTC Information
- Restraints - Revised SRS ECU Removal and Installation