Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Fuel System - 'Clean Fuel Filter' Mssg. And DTC's Stored
- Body/Lighting - Replace The Protective Strip Clips
- Heating/A/C - A/C Service Information
- Wipers/Washers - Spray Nozzle Replacement Information
- Lighting - Uprated H7 Headlamp Bulbs
- Electrical - Fuse And Relay Box
- Fuel System - Remedy For Incorrect Fuel In Tank
- Drivetrain - R/I Of The Drive Shaft
- Drivetrain- Propeller Shaft Center Bearing With Protective Caps
- A/T - 2-3 Upshift Slip During Initial Cold Acceleration
- TPMS - Tire Pressure Control (TPC) Repairs
- Steering/Suspension - Replacing Torsion Bar Mounts
- Computer/Controls - Software Retrofit Information
- Lighting - Headlamp Unit Fogged/Droplets Forming
- Body/Paint - Sliding Door Rail Paint Damage Under End Cap
- HVAC - Auxiliary Heater Shuts Down Prematurely
- HVAC - Aux. Compressor Drive Carrier Of Power Mount Breaks
- A/C - Water Entry Via Roof Air Conditioning
- Lighting - Headlamps Fogged/Leaking/Condensation
- Body - Sliding Door Cable Track Excess Resistance/Cracked/Noise
- Body - Load Compartment Sliding Door Arrester Inoperative
- Body - Front Hinged Door/Holder Noisey/ Broken
- Body - Roof In Load Compartment Leaking
- Body - Side Wall Seam Above Rear Lamps Cracked
- Parking Assist - Parktronic Indicator, Signal Tone Too Quiet
- Instruments - 'Air Filter Fouled' Lamp Is ON
- Instruments - Inaccurate Fuel Gauge Display
- Instruments - Instrument Cluster Display Message 'LA 13'
- Trailer Controls - PSM Or AAG Unit Can't Be Activated
- Fuel System - No Start/Driveability When Cold
- Brakes/Traction Control - Brake Sys. Indicator Lamps Light Up
- ABS/TCS - ESP Light ON after Engine Start
- Brakes - Rear Brake Grind Noise
- Brakes - Front Brakes Squeal
- Drivetrain - Vibrations/Noise From Propeller Shaft
- Drivetrain - Prop. Shaft Center Support Bearing Whistle Noise
- Wheels/Tires - TPMS Monitor, Special Equipment Code RY2
- Wheels/Tires - Steering Wheel Vibrations Between 70-80MPH
- A/T - Gear Range Can't Be Engaged/No Power Flow
- A/T - Limp-Home Mode And DTC 0002 'Undervoltage' Stored
- A/T - Oil Loss In Electrical Connection And Oil Pan Gasket Area
- Fuel System - High-Pressure Pump Leaking
- A/T - Hard 2-3 Upshift Or Slips, No 3rd Gear/DTC's Stored
- Wipers/Windshield - Various Rain/Light Sensor Complaints
- Chemicals,Additives
- Superceded Bulletins
- 2012120002 - 03/28/13
- VB-47_10-001 - 12/07/11
- VB-42_10-03 - 02/01/10
- VB-41_10-01 - 02/09/10
- LI27-00_P-0485524 - 09/16/12
- S-00_40-89A - 08/10/10
- S-00_40-89 - 08/09/10
- S-54_21-244 - 7/8/11
- S-07_61-89 - 7/08/11
- A/T/Drivetrain - Oil Leak At Seam Between A/T And Transfer Case
- A/T - Diag. Verification For Valve Body/Conductor Plate
- A/T - Auxiliary Oil Pump, Test For DTC P0944
- A/T - Switches To Limp Home Mode And One Or More DTC's Stored
- Engine Controls - Engine Control Module (N3/10) Flashing
- A/T - Fluid Specification Changes
- All Technical Service Bulletins
- Fuel System - 'Clean Fuel Filter' Mssg. And DTC's Stored
- Antitheft System - Interruptions In Radio Operated Systems
- Body - Gap Dimensions On Sliding And Rear-End Door
- Body/Paint - MBUSA Approved Refinishing Products For Sprinter
- Body/Frame - Corrosion Protection Without Hexavalent Chromium V
- Body/Lighting - Replace The Protective Strip Clips
- Heating/A/C - A/C Service Information
- Wipers/Washers - Spray Nozzle Replacement Information
- Lighting/Brakes - Brake Light Switch Replacement Info.
- Lighting - Uprated H7 Headlamp Bulbs
- Parktronic(R) System - Parktronic(R) Sensor Replacement Info.
- Computer/Controls - Programming Control Units
- Electrical - Fuse And Relay Box
- Fuel System - Remedy For Incorrect Fuel In Tank
- Brakes - Brake Replacement/Parts Information
- Brakes - Brake Caliper Service Information
- Drivetrain - R/I Of The Drive Shaft
- Drivetrain- Propeller Shaft Center Bearing With Protective Caps
- A/T - 2-3 Upshift Slip During Initial Cold Acceleration
- TPMS - Tire Pressure Control (TPC) Repairs
- Steering/Suspension - Replacing Torsion Bar Mounts
- Fuel System - Common Rail Leak Oil Line
- Computer/Controls - Software Retrofit Information
- Lighting - Headlamp Unit Fogged/Droplets Forming
- Body/Paint - Sliding Door Rail Paint Damage Under End Cap
- HVAC - Auxiliary Heater Shuts Down Prematurely
- HVAC - Aux. Compressor Drive Carrier Of Power Mount Breaks
- A/C - Water Entry Via Roof Air Conditioning
- Lighting - Headlamps Fogged/Leaking/Condensation
- Body - Sliding Door Cable Track Excess Resistance/Cracked/Noise
- Body - Load Compartment Sliding Door Arrester Inoperative
- Body - Front Hinged Door/Holder Noisey/ Broken
- Body - Roof In Load Compartment Leaking
- Body - Side Wall Seam Above Rear Lamps Cracked
- Parking Assist - Parktronic Indicator, Signal Tone Too Quiet
- Instruments - Load Compartment Door Opens Without Signal
- Instruments - 'Air Filter Fouled' Lamp Is ON
- Instruments - Inaccurate Fuel Gauge Display
- Instruments - Instrument Cluster Display Message 'LA 13'
- Trailer Controls - PSM Or AAG Unit Can't Be Activated
- Fuel System - No Start/Driveability When Cold
- Brakes/Traction Control - Brake Sys. Indicator Lamps Light Up
- ABS/TCS - ESP Light ON after Engine Start
- Brakes - Rear Brake Grind Noise
- Brakes - Front Brakes Squeal
- Drivetrain - Vibrations/Noise From Propeller Shaft
- Drivetrain - Prop. Shaft Center Support Bearing Whistle Noise
- Wheels/Tires - TPMS Monitor, Special Equipment Code RY2
- Wheels/Tires - Steering Wheel Vibrations Between 70-80MPH
- Wheels/Tires/Driveline - Vibrations In Vehicle
- Drivetrain - Oil Residue On Rear Axle In Pinion Seal Area
- A/T - Gear Range Can't Be Engaged/No Power Flow
- A/T - Limp-Home Mode And DTC 0002 'Undervoltage' Stored
- A/T - Oil Loss In Electrical Connection And Oil Pan Gasket Area
- Computer/Controls - Noises After Engine Is Switched Off
- Engine Controls - MIL ON And Vehicle In Limp-Home Mode
- Fuel System - High-Pressure Pump Leaking
- Campaign - Repl. DEF (AdBlue(R)) System Line
- Campaign - Replace Driver Seat Base Console
- Recall - Replace Emergency Exit Window
- Recall - Replace A-Pillar Trim
- Recall - Replace Oil Filler Neck
- A/T - Hard 2-3 Upshift Or Slips, No 3rd Gear/DTC's Stored
- Restraints - Repair And Diag. Of Airbag Wiring Harnesses
- A/T - Operating Fluid Specification Changes
- Engine Control - Engine Control Module (N3/10) Flashing
- Computers/Controls - Module Programming Precautions
- Wheels - Checking Components For Bolted Wheel Connection
- A/T - Diag. Verification For Valve Body/Conductor Plate
- Wipers/Windshield - Various Rain/Light Sensor Complaints
- Campaign - Update Control Module Software