Removal
SEAT: REAR POWER SEAT MOTOR ASSEMBLY (for Power Seat): REMOVAL
CAUTION:
Wear protective gloves. Sharp areas on the parts may injure your hands.
HINT
Before removing the rear seat, make sure to move the seat 37 mm (1.46 in.) from the rearmost position.
1. REMOVE COWL TOP VENTILATOR LOUVER Removal
2. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL
CAUTION:
Wait at least 90 seconds after disconnecting the cable from the negative (-) battery terminal to disable the SRS system.
NOTICE:
* w/ Navigation System (for HDD):
After the engine switch is turned off, the display and navigation module display (HDD navigation system) records various types of memory and settings. As a result, after turning the engine switch off, be sure to wait for the time specified in the following table before disconnecting the cable from the negative (-) battery terminal.
Waiting Time before Disconnecting Cable from Negative (-) Battery Terminal:
* When disconnecting the cable, some systems need to be initialized after the cable is reconnected Repair Instruction - Initialization.
3. REMOVE REAR SEAT CUSHION ASSEMBLY LH Removal
4. REMOVE REAR SEAT CUSHION ASSEMBLY RH Removal
5. REMOVE REAR SEATBACK ASSEMBLY LH Removal
6. REMOVE REAR SEATBACK ASSEMBLY RH Removal
7. REMOVE REAR NO. 2 SEAT ADJUSTER ASSEMBLY
(a) Remove the nut and disconnect the anchor part of the rear center seat outer belt.
(b) Remove the 4 bolts and nut and seat adjuster.
NOTICE:
Be careful not to damage the vehicle body.
(c) Disconnect the air duct from the vehicle body.
8. REMOVE REAR SEAT INNER BELT ANCHOR BRACKET ASSEMBLY LH Disassembly
9. REMOVE SEAT CLIMATE CONTROL CONTROLLER LH Disassembly
10. REMOVE SEAT CLIMATE CONTROL BLOWER LH Disassembly
11. REMOVE REAR NO. 1 SEAT ADJUSTER ASSEMBLY
(a) Remove the 4 bolts and nut and seat adjuster.
NOTICE:
Be careful not to damage the vehicle body.
(b) Disconnect the air duct from the vehicle body.
12. REMOVE REAR SEAT INNER BELT ASSEMBLY CENTER Removal
13. REMOVE REAR SEAT INNER BELT ANCHOR BRACKET ASSEMBLY RH Disassembly
14. REMOVE SEAT CLIMATE CONTROL CONTROLLER RH Disassembly
15. REMOVE SEAT CLIMATE CONTROL BLOWER RH Disassembly
16. REMOVE REAR SEAT HEADREST ASSEMBLY LH Disassembly
17. REMOVE REAR SEAT HEADREST SUPPORT LH Disassembly
18. REMOVE REAR NO. 1 SEAT HEADREST ADJUSTER SUB-ASSEMBLY LH
(a) Detach the wire harness clamp and disconnect the 2 connectors.
(b) Remove the 2 bolts.
(c) Detach the 2 claws and remove the headrest adjuster.
19. REMOVE REAR SEAT SHOULDER BELT GUIDE LH Disassembly
20. REMOVE POSITION CONTROL ECU LH Disassembly
21. REMOVE REAR SEAT CLIMATE CONTROL ECU LH Disassembly
22. REMOVE REAR SEAT COVER CAP LH Disassembly
23. REMOVE REAR SEAT LOCK BASE LH Disassembly
24. REMOVE REAR SEATBACK COVER WITH PAD LH Disassembly
25. REMOVE REAR SEATBACK CLIMATE CONTROL BLOWER LH Disassembly
26. REMOVE REAR SEAT WIRE LH
(a) Disconnect the connectors.
(b) Detach the wire harness clamps and remove the seat wire.
27. REMOVE REAR SEAT HEADREST ASSEMBLY RH Disassembly
28. REMOVE REAR SEAT HEADREST SUPPORT RH Disassembly
29. REMOVE REAR NO. 1 SEAT HEADREST ADJUSTER SUB-ASSEMBLY RH
HINT
Use the same procedures described for the LH side.
30. REMOVE REAR SEAT SHOULDER BELT GUIDE RH Disassembly
31. REMOVE POSITION CONTROL ECU RH Disassembly
32. REMOVE REAR SEAT CLIMATE CONTROL ECU RH Disassembly
33. REMOVE REAR SEAT COVER CAP RH Disassembly
34. REMOVE REAR SEAT LOCK BASE RH Disassembly
35. REMOVE REAR SEATBACK COVER WITH PAD RH Disassembly
36. REMOVE REAR SEATBACK CLIMATE CONTROL BLOWER RH Disassembly
37. REMOVE REAR SEAT WIRE RH
HINT
Use the same procedures described for the LH side.