Removal

AIR CONDITIONING: BLOWER UNIT:

REMOVAL

1. ALIGN FRONT WHEELS FACING STRAIGHT AHEAD
2. REMOVE COOL AIR INTAKE DUCT SEAL Removal

3. REMOVE ENGINE ROOM SIDE COVER LH Removal

4. REMOVE ENGINE ROOM SIDE COVER RH Removal

5. DISCHARGE REFRIGERANT FROM REFRIGERATION
(a) Start up the engine.
(b) Turn the A/C switch on.
(c) Operate the cooler compressor at an engine rpm of approximately 1,000 for 5 to 6 minutes to circulate the refrigerant and collect compressor oil remaining in each component into the cooler compressor as much as possible.
(d) Stop the engine.
(e) Using SST, let the refrigerant gas out.
SST: 09985-20010
09985-02010
09985-02050
09985-02060
09985-02070
09985-02080
09985-02090
09985-02110
09985-02130
09985-02140
09985-02150
6. DISCONNECT CABLE FROM NEGATIVE BATTERY
CAUTION: Wait for 90 seconds after disconnecting the cable to prevent airbag deployment Service Precautions

7. REMOVE FRONT FENDER PROTECTOR UPPER LH Removal

8. REMOVE FRONT FENDER PROTECTOR UPPER RH Removal

9. REMOVE ROOF DRIP SIDE FINISH MOULDING LH

10. REMOVE ROOF DRIP SIDE FINISH MOULDING RH Removal

11. REMOVE FRONT WIPER ARM HEAD CAP Removal

12. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY LH Removal

13. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY RH Removal

14. REMOVE COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY Removal

15. REMOVE WINDSHIELD WIPER MOTOR AND LINK ASSEMBLY Removal

16. SEPARATE SUCTION PIPE SUB-ASSEMBLY Removal

17. SEPARATE LIQUID TUBE SUB-ASSEMBLY Removal

18. REMOVE HEATER WATER OUTLET HOSE Removal

19. REMOVE HEATER WATER INLET HOSE Removal

20. REMOVE SHIFT LEVER KNOB SUB-ASSEMBLY (for Automatic Transmission) Removal

21. REMOVE SHIFT LEVER KNOB SUB-ASSEMBLY (for Manual Transmission) Removal

22. REMOVE UPPER NO. 1 CONSOLE PANEL GARNISH (for Automatic Transmission) Removal

23. REMOVE UPPER NO. 2 CONSOLE PANEL GARNISH (for Automatic Transmission) Removal

24. REMOVE CONSOLE PANEL SUB-ASSEMBLY (for Automatic Transmission) Removal

25. REMOVE REAR CONSOLE PANEL SUB-ASSEMBLY (for Manual Transmission) Removal

26. REMOVE FRONT CONSOLE PANEL SUB-ASSEMBLY (for Manual Transmission) Removal

27. REMOVE FRONT ASH RECEPTACLE SUB-ASSEMBLY Removal

28. REMOVE CONSOLE BOX REGISTER ASSEMBLY Removal

29. REMOVE CONSOLE BOX Removal

30. REMOVE NO. 3 INSTRUMENT PANEL REGISTER ASSEMBLY Removal

31. REMOVE CENTER LOWER INSTRUMENT CLUSTER FINISH PANEL Removal

32. REMOVE MULTI-DISPLAY WITH RADIO RECEIVER ASSEMBLY (w/ Navigation System) Removal

33. REMOVE INTEGRATION CONTROL PANEL WITH RADIO RECEIVER ASSEMBLY (w/o Navigation System) Removal

34. REMOVE LOWER NO. 2 STEERING WHEEL COVER Removal

35. REMOVE LOWER NO. 3 STEERING WHEEL COVER Removal

36. REMOVE STEERING PAD Removal

37. REMOVE STEERING WHEEL ASSEMBLY Removal

38. REMOVE STEERING COLUMN COVER (for Power Tilt and Power Telescopic Steering Column) Removal

39. REMOVE STEERING COLUMN COVER (for Manual Tilt) Removal

40. REMOVE TURN SIGNAL SWITCH ASSEMBLY WITH SPIRAL CABLE SUB-ASSEMBLY Removal

41. REMOVE FRONT DOOR SCUFF PLATE LH (w/o Illumination) Removal

42. REMOVE FRONT DOOR SCUFF PLATE LH (w/ Illumination) Removal

43. REMOVE FRONT DOOR OPENING TRIM COVER LH Removal

44. REMOVE SIDE INSTRUMENT PANEL LH Removal

45. REMOVE NO. 1 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY Removal

46. REMOVE LOWER INSTRUMENT PANEL FINISH PANEL SUB-ASSEMBLY Removal

47. REMOVE DRIVER SIDE KNEE AIRBAG ASSEMBLY Removal

48. REMOVE INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY Removal

49. REMOVE COMBINATION METER ASSEMBLY Removal

50. REMOVE FRONT DOOR SCUFF PLATE RH (w/o Illumination) Removal

51. REMOVE FRONT DOOR SCUFF PLATE RH (w/ Illumination) Removal

52. REMOVE FRONT DOOR OPENING TRIM COVER RH Removal

53. REMOVE SIDE INSTRUMENT PANEL RH Removal

54. REMOVE NO. 2 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY Removal

55. REMOVE FRONT PASSENGER SIDE KNEE AIRBAG ASSEMBLY Removal

56. REMOVE GLOVE COMPARTMENT DOOR ASSEMBLY Removal

57. REMOVE FRONT PILLAR GARNISH LH Removal

58. REMOVE FRONT PILLAR GARNISH RH
59. REMOVE NO. 1 INSTRUMENT PANEL REGISTER ASSEMBLY Removal

60. REMOVE NO. 2 INSTRUMENT PANEL REGISTER ASSEMBLY Removal

61. REMOVE NO. 3 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY Removal

62. REMOVE FRONT STEREO COMPONENT SPEAKER ASSEMBLY (w/ Front Center Speaker) Removal

63. REMOVE NO. 2 CONSOLE BOX DUCT (for Automatic Transmission) Removal

64. REMOVE NO. 1 CONSOLE BOX DUCT (for Automatic Transmission) Removal

65. REMOVE NO. 2 CONSOLE BOX DUCT (for Manual Transmission) Removal

66. DISCONNECT PASSENGER AIRBAG CONNECTOR
67. REMOVE INSTRUMENT PANEL SAFETY PAD ASSEMBLY Removal

68. REMOVE NO. 1 AIR DUCT Removal

69. REMOVE STEERING SLIDING YOKE SUB-ASSEMBLY (for 2WD) Removal

70. REMOVE NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY (for 4WD) Removal

71. REMOVE STEERING COLUMN ASSEMBLY (for Manual Tilt) Removal

72. REMOVE STEERING COLUMN ASSEMBLY (for Power Tilt and Power Telescopic Steering Column) Removal

73. REMOVE DEFROSTER NOZZLE LOWER ASSEMBLY Removal

74. REMOVE IMMOBILISER CODE ECU
75. REMOVE INSTRUMENT PANEL REINFORCEMENT ASSEMBLY Removal

76. REMOVE AIR CONDITIONER UNIT ASSEMBLY Removal

77. REMOVE NO. 2 AIR DUCT Removal

78. REMOVE AIR CONDITIONING AMPLIFIER ASSEMBLY Removal

79. REMOVE BLOWER ASSEMBLY






(a) Disconnect the connector.
(b) Remove the screw.
(c) Release the 2 claws and remove the blower assembly.