Installation
AIR CONDITIONING: BLOWER UNIT:
INSTALLATION
1. INSTALL BLOWER ASSEMBLY
(a) Install the blower assembly with the 2 screws.
(b) Connect the connector.
2. INSTALL INSTRUMENT PANEL REINFORCEMENT ASSEMBLY Installation
3. INSTALL AIR CONDITIONING AMPLIFIER ASSEMBLY Installation
4. INSTALL STEERING COLUMN ASSEMBLY Installation
5. CONNECT STEERING INTERMEDIATE SHAFT ASSEMBLY Installation
6. INSTALL NO. 1 AIR DUCT SUB-ASSEMBLY Installation
7. INSTALL REAR NO. 1 AIR DUCT Installation
8. INSTALL REAR NO. 2 AIR DUCT Installation
9. INSTALL NO. 1 CONSOLE BOX DUCT Installation
10. INSTALL NO. 3 CONSOLE BOX DUCT Installation
11. INSTALL NO. 2 CONSOLE BOX DUCT Installation
12. INSTALL FLOOR CARPET BRACKET RH
13. INSTALL FLOOR CARPET BRACKET LH
14. INSTALL INSTRUMENT PANEL SAFETY PAD ASSEMBLY (w/o DVD Player) Installation
15. INSTALL INSTRUMENT PANEL SAFETY PAD ASSEMBLY (w/ DVD Player) Installation
16. INSTALL ROOM TEMPERATURE SENSOR Installation
17. CONNECT INSTRUMENT PANEL WIRE ASSEMBLY Installation
18. INSTALL PUSH START SWITCH Installation
19. INSTALL NO. 1 INSTRUMENT PANEL MOUNTING BRACKET Installation
20. INSTALL FRONT STEREO COMPONENT SPEAKER ASSEMBLY Installation
21. INSTALL NO. 1 SPEAKER HOLE COVER Installation
22. INSTALL NO. 1 INSTRUMENT PANEL REGISTER ASSEMBLY Installation
23. INSTALL FRONT NO. 2 SPEAKER ASSEMBLY (for LH Side) Installation
24. INSTALL NO. 1 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY Installation
25. INSTALL FRONT PILLAR GARNISH LH Installation
26. INSTALL NO. 3 INSTRUMENT PANEL REGISTER ASSEMBLY Installation
27. INSTALL FRONT NO. 2 SPEAKER ASSEMBLY (for RH Side) Installation
28. INSTALL NO. 2 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY Installation
29. INSTALL FRONT PILLAR GARNISH RH Installation
30. INSTALL REAR CONSOLE BOX ASSEMBLY Installation
31. INSTALL CONSOLE REAR END PANEL SUB-ASSEMBLY Installation
32. INSTALL CONSOLE BOX CARPET Installation
33. INSTALL CONSOLE BOX POCKET Installation
34. INSTALL HEATER SEAT SWITCH CONSOLE BASE (w/o Seat Heater System) Installation
35. INSTALL HEATER SEAT SWITCH CONSOLE BASE (w/ Seat Heater System) Installation
36. INSTALL INTEGRATION CONTROL PANEL WITH RADIO RECEIVER ASSEMBLY (w/o Navigation System) Installation
37. INSTALL MULTI-DISPLAY WITH RADIO RECEIVER ASSEMBLY (w/ Navigation System) Installation
38. INSTALL NO. 2 INSTRUMENT PANEL REGISTER ASSEMBLY Installation
39. INSTALL UPPER CONSOLE PANEL ASSEMBLY WITH FRONT ASH RECEPTACLE Installation
40. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY Installation
41. INSTALL LOWER INSTRUMENT PANEL RH Installation
42. INSTALL FRONT PASSENGER SIDE KNEE AIRBAG ASSEMBLY Installation
43. INSTALL SIDE INSTRUMENT PANEL RH Installation
44. INSTALL NO. 2 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY Installation
45. INSTALL FRONT DOOR OPENING TRIM COVER RH Installation
46. INSTALL FRONT DOOR SCUFF PLATE RH Installation
47. INSTALL INSTRUMENT PANEL FINISH PANEL END RH Installation
48. INSTALL NO. 1 SWITCH HOLE BASE Installation
49. INSTALL COMBINATION METER ASSEMBLY Installation
50. INSTALL INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY Installation
51. INSTALL TURN SIGNAL SWITCH ASSEMBLY WITH SPIRAL CABLE Installation
52. INSTALL TILT & TELESCOPIC SWITCH Installation
53. INSTALL STEERING COLUMN COVER Installation
54. ADJUST SPIRAL CABLE SUB-ASSEMBLY Installation
55. INSTALL LOWER INSTRUMENT PANEL SUB-ASSEMBLY Installation
56. INSTALL INSTRUMENT PANEL FINISH PANEL END LH Installation
57. INSTALL SIDE INSTRUMENT PANEL LH Installation
58. INSTALL FRONT DOOR OPENING TRIM COVER LH Installation
59. INSTALL FRONT DOOR SCUFF PLATE LH Installation
60. INSTALL STEERING WHEEL ASSEMBLY Installation
61. INSTALL STEERING PAD Installation
62. INSTALL LOWER NO. 3 STEERING WHEEL COVER Installation
63. INSTALL LOWER NO. 2 STEERING WHEEL COVER Installation
64. INSTALL HEATER INLET WATER HOSE Installation
65. INSTALL HEATER OUTLET WATER HOSE Installation
66. INSTALL AIR CONDITIONER TUBE AND ACCESSORY Installation
67. INSTALL SUCTION HOSE SUB-ASSEMBLY Installation
68. INSTALL WINDSHIELD WIPER MOTOR AND LINK ASSEMBLY Installation
69. INSTALL FRONT FENDER TO COWL SIDE SEAL RH Installation
70. INSTALL FRONT FENDER TO COWL SIDE SEAL LH Installation
71. INSTALL COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY Installation
72. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY LH Installation
73. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY RH Installation
74. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL
75. INSPECT STEERING PAD Installation
76. INSPECT FRONT PASSENGER SIDE KNEE AIRBAG ASSEMBLY Front Passenger Side Knee Airbag Assembly
77. INSPECT SRS WARNING LIGHT
(a) Inspect the SRS warning light Diagnosis System.
78. PERFORM INITIALIZATION
NOTE: Some systems need initialization after reconnecting the negative battery terminal Repair Instruction - Initialization.
79. ADD ENGINE COOLANT Testing and Inspection
80. CHECK FOR ENGINE COOLANT LEAKS
81. CHARGE WITH REFRIGERANT Service and Repair
82. WARM UP COMPRESSOR Service and Repair
83. CHECK FOR REFRIGERANT LEAKS Service and Repair
84. INSTALL ENGINE ROOM SIDE COVER RH Installation
85. INSTALL ENGINE ROOM SIDE COVER LH Installation
86. INSTALL HOOD HINGE COVER (for RH Side) Installation
87. INSTALL HOOD HINGE COVER (for LH Side) Installation
88. INSTALL COOL AIR INTAKE DUCT SEAL Installation