Front Passenger Airbag Assembly

Front Passenger Airbag Assembly:

FRONT PASSENGER AIRBAG ASSEMBLY

REMOVAL

1. PRECAUTION

CAUTION: Be sure to read "PRECAUTION" thoroughly before servicing.

2. ALIGN FRONT WHEELS FACING STRAIGHT AHEAD
3. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL

CAUTION: Wait for 90 seconds after disconnecting the cable to prevent airbag deployment.

4. REMOVE LOWER NO. 3 STEERING WHEEL COVER
5. REMOVE LOWER NO. 2 STEERING WHEEL COVER
6. REMOVE STEERING PAD
7. REMOVE STEERING WHEEL ASSEMBLY
8. REMOVE FRONT DOOR SCUFF PLATE LH
9. REMOVE FRONT DOOR OPENING TRIM COVER LH
10. REMOVE SIDE INSTRUMENT PANEL LH
11. REMOVE INSTRUMENT PANEL FINISH PANEL END LH
12. REMOVE LOWER INSTRUMENT PANEL SUBASSEMBLY
13. REMOVE STEERING COLUMN COVER
14. REMOVE TILT & TELESCOPIC SWITCH
15. REMOVE TURN SIGNAL SWITCH ASSEMBLY WITH SPIRAL CABLE SUB-ASSEMBLY
16. REMOVE INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY
17. REMOVE COMBINATION METER ASSEMBLY
18. REMOVE NO. 1 SWITCH HOLE BASE
19. REMOVE INSTRUMENT PANEL FINISH PANEL END RH
20. REMOVE FRONT DOOR SCUFF PLATE RH
21. REMOVE FRONT DOOR OPENING TRIM COVER RH
22. REMOVE NO. 2 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY
23. REMOVE SIDE INSTRUMENT PANEL RH
24. REMOVE FRONT PASSENGER SIDE KNEE AIRBAG ASSEMBLY
25. REMOVE LOWER INSTRUMENT PANEL RH
26. REMOVE SHIFT LEVER KNOB SUB-ASSEMBLY
27. REMOVE UPPER CONSOLE PANEL ASSEMBLY WITH FRONT ASH RECEPTACLE
28. REMOVE NO. 2 INSTRUMENT PANEL REGISTER ASSEMBLY
29. REMOVE INTEGRATION CONTROL PANEL WITH RADIO RECEIVER ASSEMBLY (W/o Navigation System)
30. REMOVE MULTI-DISPLAY WITH RADIO RECEIVER ASSEMBLY (W/ Navigation System)
31. REMOVE HEATER SEAT SWITCH CONSOLE BASE (W/o Seat Heater System)
32. REMOVE HEATER SEAT SWITCH CONSOLE BASE (W/ Seat Heater System)
33. REMOVE CONSOLE BOX POCKET
34. REMOVE CONSOLE BOX CARPET
35. REMOVE CONSOLE REAR END PANEL SUBASSEMBLY
36. REMOVE REAR CONSOLE BOX ASSEMBLY
37. REMOVE FRONT PILLAR GARNISH LH
38. REMOVE NO. 1 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY
39. REMOVE FRONT NO. 2 SPEAKER ASSEMBLY (for LH Side))
40. REMOVE NO. 1 INSTRUMENT PANEL REGISTER ASSEMBLY
41. REMOVE FRONT PILLAR GARNISH RH
42. REMOVE NO. 2 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY
43. REMOVE FRONT NO. 2 SPEAKER ASSEMBLY (for RH Side)
44. REMOVE NO. 3 INSTRUMENT PANEL REGISTER ASSEMBLY
45. REMOVE NO. 1 SPEAKER HOLE COVER
46. REMOVE FRONT STEREO COMPONENT SPEAKER ASSEMBLY
47. REMOVE NO. 1 INSTRUMENT PANEL MOUNTING BRACKET
48. REMOVE PUSH START SWITCH)
49. DISCONNECT INSTRUMENT PANEL WIRE ASSEMBLY

a. Disconnect the instrument panel wire connector.

50. REMOVE ROOM TEMPERATURE SENSOR
51. REMOVE INSTRUMENT PANEL SAFETY PAD ASSEMBLY (W/o DVD Player)
52. REMOVE INSTRUMENT PANEL SAFETY PAD ASSEMBLY (W/ DVD Player)
53. REMOVE FRONT PASSENGER AIRBAG ASSEMBLY

a. Remove the 2 screws.

b. Disengage the 10 hooks and remove the front passenger airbag assembly from the instrument panel

54. REMOVE INSTRUMENT PANEL WIRE ASSEMBLY

a. Disconnect the 2 connectors.
b. Remove the clamp and the instrument panel wire assembly from the front passenger airbag assembly.

NOTE: When handling the airbag connector, take care not to damage the airbag wire harness.

INSTALLATION

1. INSTALL INSTRUMENT PANEL WIRE ASSEMBLY

a. Connect the 2 connectors.
b. Install the clamp and the instrument panel wire assembly on the front passenger airbag assembly.

NOTE: When handling the airbag connector, take care not to damage the airbag wire harness.

2. INSTALL FRONT PASSENGER AIRBAG ASSEMBLY

a. Engage the 10 hooks and install the front passenger airbag assembly on the instrument panel.

b. Install the 2 screws.

3. INSTALL INSTRUMENT PANEL SAFETY PAD ASSEMBLY (W/o DVD Player)
4. INSTALL INSTRUMENT PANEL SAFETY PAD ASSEMBLY (W/ DVD Player)
5. INSTALL ROOM TEMPERATURE SENSOR
6. CONNECT INSTRUMENT PANEL WIRE ASSEMBLY

a. Connect the instrument panel wire connector.

7. INSTALL PUSH START SWITCH
8. INSTALL NO. 1 INSTRUMENT PANEL MOUNTING BRACKET
9. INSTALL FRONT STEREO COMPONENT SPEAKER ASSEMBLY
10. INSTALL NO. 1 SPEAKER HOLE COVER
11. INSTALL NO. 1 INSTRUMENT PANEL REGISTER ASSEMBLY
12. INSTALL FRONT NO. 2 SPEAKER ASSEMBLY (for LH Side)
13. INSTALL NO. 1 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY
14. INSTALL FRONT PILLAR GARNISH LH
15. INSTALL NO. 3 INSTRUMENT PANEL REGISTER ASSEMBLY
16. INSTALL FRONT NO. 2 SPEAKER ASSEMBLY (for RH Side)
17. INSTALL NO. 2 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY
18. INSTALL FRONT PILLAR GARNISH RH (See
19. INSTALL REAR CONSOLE BOX ASSEMBLY
20. INSTALL CONSOLE REAR END PANEL SUBASSEMBLY
21. INSTALL CONSOLE BOX CARPET
22. INSTALL CONSOLE BOX POCKET
23. INSTALL HEATER SEAT SWITCH CONSOLE BASE (W/o Seat Heater System))
24. INSTALL HEATER SEAT SWITCH CONSOLE BASE (W/ Seat Heater System)
25. INSTALL INTEGRATION CONTROL PANEL WITH RADIO RECEIVER ASSEMBLY (W/o Navigation System)
26. INSTALL MULTI-DISPLAY WITH RADIO RECEIVER ASSEMBLY (W/ Navigation System)
27. INSTALL NO. 2 INSTRUMENT PANEL REGISTER ASSEMBLY
28. INSTALL UPPER CONSOLE PANEL ASSEMBLY WITH FRONT ASH RECEPTACLE
29. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY
30. INSTALL LOWER INSTRUMENT PANEL RH
31. INSTALL FRONT PASSENGER SIDE KNEE AIRBAG ASSEMBLY
32. INSTALL SIDE INSTRUMENT PANEL RH
33. INSTALL NO. 2 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY
34. INSTALL FRONT DOOR OPENING TRIM COVER RH
35. INSTALL FRONT DOOR SCUFF PLATE RH
36. INSTALL INSTRUMENT PANEL FINISH PANEL END RH
37. INSTALL NO. 1 SWITCH HOLE BASE
38. INSTALL COMBINATION METER ASSEMBLY
39. INSTALL INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY
40. INSTALL TURN SIGNAL SWITCH ASSEMBLY WITH SPIRAL CABLE SUB-ASSEMBLY
41. INSTALL TILT & TELESCOPIC SWITCH
42. INSTALL STEERING COLUMN COVER
43. ADJUST SPIRAL CABLE
44. INSTALL LOWER INSTRUMENT PANEL SUBASSEMBLY
45. INSTALL INSTRUMENT PANEL FINISH PANEL END LH
46. INSTALL SIDE INSTRUMENT PANEL LH
47. INSTALL FRONT DOOR OPENING TRIM COVER LH
48. INSTALL FRONT DOOR SCUFF PLATE LH
49. INSTALL STEERING WHEEL ASSEMBLY
50. INSTALL STEERING PAD
51. INSTALL LOWER NO. 3 STEERING WHEEL COVER
52. INSTALL LOWER NO. 2 STEERING WHEEL COVER
53. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

54. PERFORM INITIALIZATION
a. Perform initialization.

HINT: Some systems need initialization after reconnecting the cable to the negative battery terminal.

55. INSPECT STEERING PAD
56. INSPECT FRONT PASSENGER SIDE KNEE AIRBAG ASSEMBLY
57. INSPECT FRONT PASSENGER AIRBAG ASSEMBLY

58. INSPECT SRS WARNING LIGHT
a. Inspect the SRS warning light.