Installation

PARKING BRAKE: PARKING BRAKE PEDAL: INSTALLATION

1. INSTALL PARKING BRAKE CONTROL PEDAL ASSEMBLY

(a) Install the parking brake control pedal assembly with the 3 nuts.





Torque : 39 Nm (398 kgf-cm, 29 ft-lbf)

(b) Engage the 2 clamps to install the wire harness clamp.





(c) Connect the parking brake switch connector.





(d) Insert the No. 1 parking brake cable assembly toward the outside of the cabin.





(e) Install the No. 1 parking brake cable assembly with the 2 bolts and 2 nuts.





Bolt - Torque : 8.5 Nm (87 kgf-cm, 75 in-lbf)

Nut - Torque : 6.0 Nm (61 kgf-cm, 53 in-lbf)

(f) Install the clamp.

(g) Temporarily install the lock nut.





Text in Illustration





HINT
After adjusting parking brake pedal travel, tighten the lock nut.

2. INSTALL INSTRUMENT PANEL JUNCTION BLOCK ASSEMBLY Installation

3. INSTALL PARKING BRAKE EQUALIZER

(a) Install the parking brake equalizer to the No. 1 parking brake cable assembly as shown in the illustration.





(b) Slide the rubber boot back as shown in the illustration.





4. CONNECT NO. 3 PARKING BRAKE CABLE ASSEMBLY

(a) Connect the No. 3 parking brake cable assembly to the parking brake equalizer.





5. CONNECT NO. 2 PARKING BRAKE CABLE ASSEMBLY

HINT
Perform the same procedure as for the No. 3 parking brake cable assembly.

6. INSTALL REAR ENGINE SERVICE COVER ASSEMBLY

(a) Install the rear engine service cover assembly with the 2 bolts.





7. INSTALL CENTER FRONT FLOOR COVER

(a) Engage the 4 clips to install the center front floor cover.





(b) Install the 4 bolts, 2 screws and nut.





8. INSTALL FRONT FLOOR FOOTREST

(a) Engage the 2 clips to install the front floor footrest.





9. INSTALL REAR NO. 1 AIR DUCT

(a) Install the rear No. 1 air duct.





(b) Engage the wire harness clamp.

10. INSTALL REAR NO. 2 AIR DUCT

(a) Install the rear No. 2 air duct with the clip.





(b) Install the floor carpet.

11. INSTALL CONSOLE BOX Installation

12. INSTALL FRONT CONSOLE BOX COVER Installation

13. INSTALL INSTRUMENT PANEL FINISH PANEL Installation

14. INSTALL DRIVER SIDE KNEE AIRBAG ASSEMBLY

HINT
Refer to the instructions for Installation of the driver side knee airbag assembly Installation.

15. INSTALL REAR CONSOLE BOX ASSEMBLY

HINT
Refer to the instructions for Installation of the rear console box Installation.

16. INSTALL FRONT SEAT ASSEMBLY LH

HINT
Refer to the instructions for Installation of the front seat assembly Installation.

17. ADJUST PARKING BRAKE SHOE CLEARANCE AND PARKING BRAKE PEDAL TRAVEL Adjustments

18. INSPECT BRAKE WARNING LIGHT Adjustments