Charging System - Battery Lamp ON/Multiple DTC's Set
TSB 11-7-1307/12/11
BATTERY LIGHT ON - DTCS MAY ALSO BE
PRESENT UO12D, U0140, B11DB, U0422, P2610,
P06B8 OR U0257
FORD:
2012 Focus
ISSUE
Some 2012 Focus vehicles built on or before 5/25/2011 may experience a battery light on. The following diagnostic trouble codes (DTCs) may also be present: U012D, U0140, B11DB, U0422, P2610, P06B8 or U0257.
ACTION
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
1. Using IDS, check for DTCs U012D, U0140, B11DB, U0422, P2610, P06B8, or U0257. Are any of the DTCs present with the battery light on?
a. Yes - proceed to Step 2.
b. No - discontinue this procedure. Refer to Workshop Manual (WSM), Section 414-00 for normal diagnostics.
2. Disconnect connector C1651 at the active grille shutter actuator.
3. Start the vehicle.
a. If the battery light is on and DTC UO12D is present; proceed to Step 4.
b. If the battery light is off, do not continue with this article. Refer to WSM, Section 501-02 or 414-00 for normal diagnostics.
4. Replace the generator. Refer to the WSM, Section 414-00.
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION DESCRIPTION TIME
110713A 2012 Focus: Replace 0.8 Hr.
Generator, Includes Time
To Perform Diagnosis In
Service Procedure (Do Not
Use With Any Other Labor
Operations)
DEALER CODING
CONDITION
BASIC PART NO. CODE
10346 42
Disclaimer