Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 03V482000: Fuel Pump Warranty Extension
- Recall - Fuel Delivery Module Defect
- Recall 02V289000: Steering Knuckle Bolt Inspection
- Recall - Pinch Bolt Torque and Battery Cable Routing
- Recall - Rear Door Latch Corrosion/Won't Latch Correctly
- Recall 02V288000: Battery Cable Fire Hazard
- Recall 01V258000: Wiper Motor Gear Case Cover
- Recall - Defective Wiper Motor Switch/Gear Cover
- Recall 05V030000: Rear Door Latch Corrosion
- Recall 00V418000: Rear Seat Hinge Pivot Defect
- Recall 01V108000: Seat Recliner Handle Spring Defect
- Recall - Seat Back Recliner Handle Spring Replacement
- Customer Interest
- Engine - Vibration At Idle
- Brakes - Excessive Brake Dust on Wheels
- Engine - MIL ON/Misfire DTC's/Driveability Concerns
- A/C - Water in Blower Motor Case
- Suspension - Creak, Crunch, Grinding or Rattle Noise
- MIL ON - DTC's P0300 Thru P0304 Set
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Emissions - MIL ON/DTC's Set/Ticking Noise (DPFE Sensor)
- Emissions - MIL ON/DTC's P0402/P0403/Runs Rough
- Brakes - Rear Drum Brake Squealing Noises
- CPM - MIL ON DTC P0118 Stored in Memory
- Engine - Hesitation at Cruise or Light Tip In
- A/T - Reprogram PCM After Installing Revised Transaxle
- Engine Controls - Hard Start/Driveability Issues
- Electrical - Horn Inoperative
- Body, A/C - Water Leaks to Vehicle Interior
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Body - Hood Latch Difficult/Unable to Open
- Body - Corrosion At Bottom of Door or Tailgate
- Suspension - Rear Tire Inner Edge Wear
- Lighting - Turn Signal Lamps Won't Self-Cancel
- Interior - Carpet Pulling Away From R/H Kick Panel
- M/T - Hard to Shift Gears
- Ignition System - Cannot Remove/Turn Key/Chime ON
- Evaporator Case/Cowl - Interior Water leaks
- A/C - Heater Core Electrolysis/Leakage
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Interior - Console Arm Rest Pivot Loose
- Brakes - Rear Drum Brake Squealing Noise
- M/T - Clutch Pedal Squeaks/Excessive Free Play
- Superceded Bulletins
- 07-12-4 -06/25/07
- 03N01 - 11/01/03
- 02M01 - 01/01/04
- 02M01 - 11/01/03
- Rear Window Defroster - Inoperative
- Interior - Carpet Pulling Away From Kick Panel
- Recall - Rear Door Latch Inspection/Door Seal Install
- Recall - Rear Door Latch Corrosion
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Suspension - Front Suspension Creaking/Crunching
- Suspension - Creaking/Grinding on Turns/Bumps
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Electrical - Wiring Harness Replacement Tips
- Electrical - Wire Harness Replacement Service Tips
- Electrical - Wiring Harness Replacement Guidelines/Tips
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Brakes - Rear Drum Brake Squealing Upon Application
- M/T - Clutch Pedal Squeak/Excessive Free Play
- Ignition - Key Hard to Turn/Remove from Ignition Lock
- Interior - Ignition Lock Cylinder Hard to Turn
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Emissions - MIL ON, DTC's P0401, P1400 or P1401
- Emissions - MIL ON/Possible DTC's/Driveability Issues
- Emissions - MIL ON/DTC's Set/Driveability Concerns
- Emissions - MIL ON/EVAP System DTC's Set
- PCM - DTC's P1635 or P1639 Set/4X4 Lamp ON
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Engine - Excessive Vibration At Idle
- Engine - Vibrates At Idle
- Engine - Excessive Idle Vibration
- Engine - Vibrates at Idle
- Engine - Vibration At Idle
- Engine - Vibration at Idle
- Engine - Excessive Vibration at Idle
- Engine - Low Power/Stalling/DTC's P0300-P0304 Set
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Campaign - Rear Wheel Bearing Replacement
- Campaign - Rear Hub Bearing Kit Installation
- Engine - Oil Recommendations/Applications
- Emissions- DTC's Set/MIL ON/Driveability Concerns
- All Technical Service Bulletins
- Engine - Vibration At Idle
- A/C System - Diagnosis and Service Tips
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Recall 03V482000: Fuel Pump Warranty Extension
- Fuel Delivery Module - Replacement Procedure
- Recall - Fuel Delivery Module Defect
- Brakes - Excessive Brake Dust on Wheels
- Engine - MIL ON/Misfire DTC's/Driveability Concerns
- A/C - Water in Blower Motor Case
- Suspension - Creak, Crunch, Grinding or Rattle Noise
- Campaign - Rear Wheel Bearing Seal Replacement
- MIL ON - DTC's P0300 Thru P0304 Set
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Recall 02V289000: Steering Knuckle Bolt Inspection
- Recall - Pinch Bolt Torque and Battery Cable Routing
- Campaign - Coil Spring Corrosion Warranty Extension
- Wheels/Tires - Road Force Measurement Equipment
- Warranty - Guide Supplement
- Information
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor Information
- Attachment III - Technical Information
- Owner Letter
- Supplement # 1 - Information
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Owner Letter
- Supplement # 2 - Information
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Apology Letter
- Supplement # 2 - Owner Letter
- Recall - Rear Door Latch Corrosion/Won't Latch Correctly
- A/T - Cooler Flushing Service Tips
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Emissions/Engine Controls - Driveability Diagnosis
- Emissions - MIL ON/DTC's Set/Ticking Noise (DPFE Sensor)
- Emissions - MIL ON/DTC's P0402/P0403/Runs Rough
- Brakes - Rear Drum Brake Squealing Noises
- Recall 02V288000: Battery Cable Fire Hazard
- CPM - MIL ON DTC P0118 Stored in Memory
- Engine - Hesitation at Cruise or Light Tip In
- A/T - Reprogram PCM After Installing Revised Transaxle
- Engine Controls - Hard Start/Driveability Issues
- Engine Controls - General PCM Programming Procedures
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Electrical - Horn Inoperative
- Recall 01V258000: Wiper Motor Gear Case Cover
- Recall - Defective Wiper Motor Switch/Gear Cover
- Engine Head Gasket - Approved Replacement Procedures
- Body, A/C - Water Leaks to Vehicle Interior
- PATS System - Diagnostic Service Tips
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Engine Controls - MIL ON/Lean DTC Service Tips
- Body - Hood Latch Difficult/Unable to Open
- Recall 05V030000: Rear Door Latch Corrosion
- Body - Corrosion At Bottom of Door or Tailgate
- Body - Corrosion Damage On Liftgate/Deck Lid
- Body - Exterior Mirror Glass/Motor Service Tips
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - 'Prior To Repair' Tag Procedure Notice
- Drivetrain - Intermediate Axle Shaft Bearing Replacement
- Suspension - Rear Tire Inner Edge Wear
- Lighting - Turn Signal Lamps Won't Self-Cancel
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Electrical - Wiring Soldering/Crimping Service Tips
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- Interior - Carpet Pulling Away From R/H Kick Panel
- M/T - Hard to Shift Gears
- Ignition System - Cannot Remove/Turn Key/Chime ON
- Evaporator Case/Cowl - Interior Water leaks
- Recall 00V418000: Rear Seat Hinge Pivot Defect
- Recall 01V108000: Seat Recliner Handle Spring Defect
- Fuel System - Fuel Pressure Relief Valve Eliminated
- Recall - Seat Back Recliner Handle Spring Replacement
- A/C - Heater Core Electrolysis/Leakage
- Keyless Entry - Keypad Diagnostics
- Emissions - Revised EGR Tube Service Procedure
- Steering - Mercon V(R) Fluid Usage
- Electrical - Wiring Harness Replacement Guidelines
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Interior - Console Arm Rest Pivot Loose
- Steering/Frame - Vehicle Pulling or Drifting
- Brakes - Rear Drum Brake Squealing Noise
- M/T - Clutch Pedal Squeaks/Excessive Free Play