Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 97V165000: Steering Gear Damaged
- Recall 97V165002: Steering Gear Damage
- Recall 97V165002: Steering Rack Damaged
- Recall 97V216000: Fuel Rail Bracket Defect
- Recall 00V349000: Hood Striker Fracture/Failure
- Recall 99V062001: Cruise Control Cables, Binding
- Recall - Speed Control Cable Replacement
- Overview
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Question and Answer Sheet
- Owner Letter
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Owner Letter
- Recall 99V062000: Sticking Cruise Control Cable
- Recall - Park Brake Control Modification
- Overview
- Dealer Letter - October 2000
- Dealer Letter - November 2000
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Example Mustang Owner Guide
- Owner Letter
- Supplement #1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Attachment IV
- Supplement # 1 - Owner Letter
- Customer Interest
- A/C System - Musty/Mildew Odors
- Engine - Coolant Loss/Oil Contamination
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- A/T Cooler - Fluid Leaks at Radiator
- Engine Mount/Frame - Vibration/Shake
- Clutch - Vibration/Noise Felt In Clutch Pedal
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine - Lean Driveability Symptoms
- Body - Road Noise/Dust/Water in Luggage Compartment
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- A/T - 4R70W TCIL ON/Code P0782/Delayed/No 2-3 Upshift
- Hood - Difficult to Close
- Windshield - Water Leaks
- Rocker Panel Mouldings - Loose
- Exhaust System - Buzzing/Rattling Noise
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Convertible Top Boot - Improper Fit
- Paint - Rough Texture
- A/T - Inadvertent Shift Interlock Disabling
- A/T - 4R70W (Remanufactured) Delayed or No 2-3 Upshift
- M/T - T45 Stuck In Reverse/Pops Out Of Reverse
- Front Window - Travels Out Of The Glass Run
- A/C - Heater Core Electrolysis/Leakage
- Chemicals,Additives
- Labor/Parts Updates
- Seals, Gaskets
- Superceded Bulletins
- Paint - Materials For Warranty And Post Warranty Repair
- Locks - Lock Service Package Availability
- Locks - Lock Service Kit Availability
- Locks - Lock Service Kits Availability
- Interior Trim - Repairs To Vinyl Surfaces
- Passive Antitheft System (PATS) - Diagnostics Tips
- Passive Antitheft System - Diagnostic Tips
- Passive Antitheft System (PATS) - Diagnostic Tips
- Passive Anti Theft System - Diagnostic Service Tips
- A/C - Musty/Mildew Type Odors
- A/C - Identification Of Non Approved Refrigerants
- A/C - Musty And Mildew Type Odors
- A/T - 4R70W Delayed Or No 2-3 Upshift
- Electrical - Wiring Soldering/Crimping Tips
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Passive Antitheft System - Diagnostic Service Tip
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Brakes - Roughness/Vibration
- Brake Rotor - Hub Mounted Machining Equipment
- Clutch - Noise/Vibration Felt In The Clutch Pedal
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Brake Shift Interlock - Inadvertent Disabling
- A/T - Fluid Leak At Radiator Oil Cooler
- Speaker - Whining/Buzzing Noise
- Speakers - Whining/Buzzing Noise
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- EVAP - MIL ON/DTC's P0442/P0455/No Driveability Concerns
- EVAP System - MIL ON/DTC's P0442/P0455 Stored
- Emissions - MIL ON/EVAP System DTC's Set
- PCM - Out Of Vehicle Reprogramming
- Exhaust System - Buzzing/Rattling Noises
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Engine - Oil Mixed With Coolant/Coolant Loss
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Engine - Oil Recommendations/Applications
- Automatic Transmission - Fluid Usage Charts
- A/C - Identifying Non-Approved Refrigerants
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- All Technical Service Bulletins
- A/C - Filtering Refrigerant After Compressor Replacement
- A/C System - Musty/Mildew Odors
- A/C System - Diagnosis and Service Tips
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Engine - Coolant Loss/Oil Contamination
- Electrical - New Terminal Grease Released For Service
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Recall 97V165000: Steering Gear Damaged
- Recall 97V165002: Steering Gear Damage
- Recall 97V165002: Steering Rack Damaged
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- A/T Cooler - Fluid Leaks at Radiator
- Wheels/Tires - Road Force Measurement Equipment
- Engine Mount/Frame - Vibration/Shake
- Clutch - Vibration/Noise Felt In Clutch Pedal
- A/T - Cooler Flushing Service Tips
- Clutch Pedal - Vibration Heard or Felt
- Fuel Injectors - Non Warranty Reimbursement Testing
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- PCM - Reprogramming Out of Vehicle
- Emissions/Engine Controls - Driveability Diagnosis
- Engine - Lean Driveability Symptoms
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- Engine Controls - General PCM Programming Procedures
- Recall 97V216000: Fuel Rail Bracket Defect
- Hub-Mount Brake Rotor Machining Equipment
- Engine Head Gasket - Approved Replacement Procedures
- Paint - Anti Chip Stone Abrasion Undercoat Service Tip
- Safety Certification Label - Cleaning Precautions
- Body - Structural Adhesive Recommendations
- Body - Road Noise/Dust/Water in Luggage Compartment
- PATS System - Diagnostic Service Tips
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- EVAP System - Diagnosis and Testing
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- A/T - Multiple DTC's Stored Diagnosis
- A/T - 4R70W TCIL ON/Code P0782/Delayed/No 2-3 Upshift
- Hood - Difficult to Close
- Recall 00V349000: Hood Striker Fracture/Failure
- Interior Door Trim Panel - Replacement Tip
- Windshield - Water Leaks
- Body - Exterior Mirror Glass/Motor Service Tips
- Rocker Panel Mouldings - Loose
- Motor Oil - Viscosity Grade Recommendation
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- Exhaust System - Buzzing/Rattling Noise
- A/T - 4R70W Orange Service Tag Service Procedure
- A/T - Cold Fluid Level Checking
- A/T - In Line Fluid Filter Kit
- A/T - Transmission Flush and Fill Tool Available
- Recall 99V062001: Cruise Control Cables, Binding
- Recall - Speed Control Cable Replacement
- Overview
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Question and Answer Sheet
- Owner Letter
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Owner Letter
- Recall 99V062000: Sticking Cruise Control Cable
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Engine - New Gasket Sealer
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Convertible Top Boot - Improper Fit
- Keyless Entry System - Service Tips
- Interior Trim - Vinyl Surface Repair Tips
- Locks - Lock Service Packages Available
- Paint - Surface Defect Removal Without Repainting
- Paint - Materials For After Warranty/Warranty Repairs
- Paint - Rough Texture
- A/T - Inadvertent Shift Interlock Disabling
- A/T - 4R70W (Remanufactured) Delayed or No 2-3 Upshift
- A/C - Identification of Non Approved Refrigerants
- M/T - T45 Stuck In Reverse/Pops Out Of Reverse
- A/T - 4R70W Needle Bearing/Race Kit Service Tip
- Front Window - Travels Out Of The Glass Run
- Brakes - Vibration/Inspection Service Tips
- Recall - Park Brake Control Modification
- Overview
- Dealer Letter - October 2000
- Dealer Letter - November 2000
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Example Mustang Owner Guide
- Owner Letter
- Supplement #1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Attachment IV
- Supplement # 1 - Owner Letter
- Fuel - Volatility Related Driveability Concerns
- Seat Leather - Cleaning Procedure Tips
- A/C - Heater Core Electrolysis/Leakage
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Comprehensive Noise/Vibration/Harshness Procedure
- Overview
- Description and Operation
- Diagnosis and Testing
- Overview
- Diagnostic Process
- 1. Customer Interview
- 2. Pre-Drive Check
- 3. Preparing For the Road Test
- 4. Verify the Customer Concern
- 5. Road Test
- 6. Check OASIS/TSBs/Repair History
- 7. Diagnostic Procedure
- NVH Condition and Symptom Categories
- Symptom Charts
- Pinpoint Tests
- Overview
- Pinpoint Test A: Brake Vibration/Shudder Diagnosis
- Pinpoint Test B: Engine Ticking Noise Diagnosis
- Pinpoint Test C:Front ENG. ACC. Drive (Fead) Bearing Hoot Diag.
- Pinpoint Test D: Power Steering Moan Diagnosis
- Pinpoint Test E: Engine Driven Cooling Fan Moan Diagnosis
- Pinpoint Test F: Drumming Noise Diagnosis
- Pinpoint Test G: Engine Ticking, Knock/Continuous Rattle Diag.
- Pinpoint Test H: Front Suspension Noise Diagnosis
- Pinpoint Test I: Rear Suspension Noise Diagnosis
- Pinpoint Test J: Wheel and Tire Diagnosis
- Pinpoint Test K: High Speed Shake or Shimmy Diagnosis
- Pinpoint Test L: Clutch Vibration
- Pinpoint Test M: Transfer Case Vibration
- Component Tests
- Tire Wear Patterns & Frequency Calculations
- General Procedures