Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Safety
- Recall 04V244000: Liftgate Glass Strut/Hinge Defect
- Recall - Replace Liftgate Glass Ball Stud Bracket/Hinge
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Dealer Questions and Answers
- Attachment V - Important Parts Notification
- Owner Letter - Built From 3/10/02 (SLAP) or 3/3/02 (LAP)
- Owner Letter - Built From 3/11/02 (SLAP) or 3/4/02 (LAP)
- Recall - Cruise Control Deactivation Switch Overheating
- Customer Interest
- Brakes - Adjustable Brake Pedal Adjustment Inoperative
- Fuel System - Hesitation on Hard Sweeping Right Turns
- A/C - Moan/Buzz/Groan Noise From Vehicle Rear
- Drivetrain - Rear Axle Hub Bearing Noise
- Driveline - Vibration/Boom Between 55 and 75 MPH
- Drivetrain - Rear Differential Whine/Hum Noise
- Engine Controls - No Start Condition
- Instruments - Fuel Gauge Drops to Empty/MIL ON/DTC's
- Brakes - ABS Lamp ON/DTC's C1235/C1236/C1237 Set
- Engine Controls - Hard or No Start After Short Hot Soak
- Body - Rear Windows Inoperative
- Headlights - Moisture Inside
- Restraint System - Air Bag Lamp ON/DTC B2292 Set
- A/T - 5R55W 2-3 Shift Slip/No 3rd gear/DTC's P0733/P0745
- Body - Back Glass Hard to Close/Door Ajar Lamp ON
- Drivetrain - Limited Slip Differential Chatter
- Body - Liftgate Glass Applique Damaged/Cracking
- Restraints - Seat Belts Slow to Retract
- Body - Roof Rack Side Rail Paint Peeling
- M/T - Shudder/Vibration On 2nd/3rd Gear Acceleration
- A/T, Drivetrain - Shudder in 2nd and 3rd Gear
- A/C - Drive Belt Chirp When A/C Compressor Engages
- Audio System - Delayed Power When Switched ON
- A/T - Inadvertent Shift Interlock Disabling
- A/T - Hard To Shift From DRIVE to PARK
- Engine - Timing Chain Rattle Noise
- Interior - Front Seat Movement On Accel./Decel.
- A/C - Low Rpm Hooting Noise
- Body - Moonroof Squeak or Rattle Noise
- Instruments - False Parking Aid Warnings
- A/C - Heater Core Electrolysis/Leakage
- Starting System- No Crank Condition
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Body - Rear Door Window Stuck In Up Position/Inoperative
- 4X4/AWD System - Shudder On Accel/Decel/Binding On Turns
- Drivetrain - Rear Axle Seal(s) Leaking
- A/T - Loss Of 2nd/3rd/5th Gears/Ratio DTC's Set
- Superceded Bulletins
- 04S20S1 - 11/01/04
- 03-12-6 - 08/04/03
- 02M01S3 - 01/01/04
- 02M01S2 - 01/01/04
- 02M01S5 - 04/01/04
- Body - Rear Power Window(s) Stuck In UP Position
- Body - Rear Power Windows Inoperative
- Rear Window Defroster - Inoperative
- Instruments - Fuel Gauge Slow to Update After Fill-Up
- Body - Aluminum Corrosion Service Tip
- Recall - Seat Back Recliner Bolt Defect
- Body - Liftgate Glass Applique Cracked/Damaged
- Body - Liftgate Glass Applique Damaged/Cracked
- Recall - Liftgate Hinge Ball/Stud Bracket Replacement
- Body - Rear Power Window Stuck in Up Position/Inop.
- Parking Assist System - False Warnings
- Parking Assist System - False Tone Activation
- Parking Assist System - False Activation
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Restraint System - Seat Belts Slow to retract
- Restraints - DTC And Associated Fault PID Service Tips
- Electrical - Wiring Soldering/Crimping Tips
- Battery - Service/Charging Tips
- Driveline - Vibration/Boom at 55 - 75 MPH
- Drivetrain - Rear Halfshaft Axle Seal Leaks
- Drivetrain - Drive Axle Whine/Hum on Accel/Decel/Cruise
- Drivetrain - Rear Halfshaft Seal Oil Leaks
- Drivetrain - L/S Differential Chatter on Low Speed Turns
- Drivetrain - L/S Rear Axle Shudder/Chatter
- Drivetrain - LS Drive Axle Chatter/Shudder on Turns
- Drivetrain - Rear Axle Whine or Hum
- Instruments - MIL ON/DTC's/Fuel Gauge Slow to Rise
- Engine Controls - General PCM Reprogramming Procedures
- Recall - EGR Pressure Sensor Replace/Warranty Extension
- Emissions - MIL ON, DTC's P0401, P1400 or P1401
- A/T - 5R55W No 3rd Gear/Slipping 2-3 Shift/DTC's Set
- Emissions - MIL ON/Possible DTC's/Driveability Issues
- Emissions - MIL ON/EVAP System DTC's Set
- Battery - Battery EYE Function/Charging Service Tips
- Drivetrain - Rear Wheel Bearing Noise
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- All Technical Service Bulletins
- Brakes - Adjustable Brake Pedal Adjustment Inoperative
- Fuel System - Hesitation on Hard Sweeping Right Turns
- A/C - Evaporator Core Replacement
- A/C - Moan/Buzz/Groan Noise From Vehicle Rear
- Drivetrain - Rear Axle Hub Bearing Noise
- Driveline - Vibration/Boom Between 55 and 75 MPH
- Drivetrain - Rear Differential Whine/Hum Noise
- Engine Controls - No Start Condition
- Instruments - Fuel Gauge Drops to Empty/MIL ON/DTC's
- Emissions - MIL ON/Driveability Issues/DTC's Set
- Recall - Tube Mounted EGR Pressure Sensor Defect
- Brakes - ABS Lamp ON/DTC's C1235/C1236/C1237 Set
- Engine Controls - General PCM Programming Procedures
- Engine Controls - Hard or No Start After Short Hot Soak
- Fuel System - Throttle Cable Routing/Splash Shield Mods
- Body - Rear Windows Inoperative
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Headlights - Moisture Inside
- PATS System - Diagnostic Service Tips
- Restraint System - Air Bag Lamp ON/DTC B2292 Set
- Engine Controls - MIL ON/Lean DTC Service Tips
- A/T - 5R55W 2-3 Shift Slip/No 3rd gear/DTC's P0733/P0745
- Body - Back Glass Hard to Close/Door Ajar Lamp ON
- Drivetrain - Limited Slip Differential Chatter
- Recall 04V244000: Liftgate Glass Strut/Hinge Defect
- Recall - Replace Liftgate Glass Ball Stud Bracket/Hinge
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Dealer Questions and Answers
- Attachment V - Important Parts Notification
- Owner Letter - Built From 3/10/02 (SLAP) or 3/3/02 (LAP)
- Owner Letter - Built From 3/11/02 (SLAP) or 3/4/02 (LAP)
- Body - Liftgate Glass Applique Damaged/Cracking
- Restraints - Seat Belts Slow to Retract
- Body - Exterior Mirror Glass/Motor Service Tips
- Body - Roof Rack Side Rail Paint Peeling
- M/T - Shudder/Vibration On 2nd/3rd Gear Acceleration
- A/T, Drivetrain - Shudder in 2nd and 3rd Gear
- A/C - Drive Belt Chirp When A/C Compressor Engages
- A/T - 5R55W Correct Fluid Checking Procedure
- Electrical - Wiring Soldering/Crimping Service Tips
- Cruise Control - Diagnostics Updates
- Keyless Entry System - Service Tips
- Audio System - Delayed Power When Switched ON
- Paint - New Polishing Products and Procedures
- Paint - Premature Clearcoat Cracking Service Tips
- Paint - Plastic Bumper/Fascia Service Tips
- A/T - Inadvertent Shift Interlock Disabling
- A/T - Hard To Shift From DRIVE to PARK
- Engine - Timing Chain Rattle Noise
- Interior - Front Seat Movement On Accel./Decel.
- A/C - Low Rpm Hooting Noise
- Body - Moonroof Squeak or Rattle Noise
- Instruments - False Parking Aid Warnings
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Starting System- No Crank Condition
- Body - Aluminum Body Panels - Corrosion
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Restraints - Control Module DTCs, Associated Fault PIDs
- Body - Rear Door Window Stuck In Up Position/Inoperative
- 4X4/AWD System - Shudder On Accel/Decel/Binding On Turns
- Drivetrain - Rear Axle Seal(s) Leaking
- A/T - Loss Of 2nd/3rd/5th Gears/Ratio DTC's Set
- Recall - Cruise Control Deactivation Switch Overheating