Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Safety
- Recall 96V158002: Fuel Pump/Gauge Unit Gasket Leak
- Recall - Lower Lateral Arm Ball Joint Boots
- Recall 99V066003: Lower Ball Joint Separation
- Recall 00V421002: Lower Lateral Arm Ball Joint Wear
- Recall - Transfer Case Oil Leak
- Recall 98V069002: Transfer Case Lockup
- Recall - Fuel Tank Leak
- Recall 94V149001: ABS Hydraulic Unit Attachment Failure
- Recall - Passenger Air Bag Safety
- Recall 96V158000: Fuel Pump/Fuel Gauge Unit Gasket Leak
- Customer Interest
- Brakes - Pulsation/Shudder
- Spark Plugs - Hard Start/Misfire Or Rough Idle
- Rear Shock - Thump/Chuckle or Creak Noise
- Front Suspension - Knocking, Clunking Noise
- Door Panel/Speaker - Buzz and Rattle
- Converter Clutch - Vehicle Shudder on Lock Up
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Ratcheting Sound When Coming To Stop
- PCM - O2 Sensor Faults/MIL ON
- Purge Solenoid - Ticking Noise at Idle
- A/T - Shudder on 1 - 2/2 - 3 Upshift
- A/T - MIL ON/DTC's Set
- Power Seat Switch - Sticks
- Theft Alarm - Intermittent/Random Activation
- Door Ajar Lamp/Dome Lamp - Intermittent Operation
- Black Plastic Body Components - Chalky Residue
- Rear Quarter Trim - Buzz or Rattle
- Door - Popping/Rattle/Squeak
- Sunroof - Inoperative/Opens By Itself
- Wipers/Washers - Wipers Smear or Streak Windshield
- Windshield Washer Nozzles - Fluid Leaks
- Front Suspension/Alignment - Vehicle Drift or Lead
- Rear Trailing Arm - Squeaking or Rubbing Sound
- Ignition Key - Difficult to Remove From Cylinder
- Speed Sensor - Intermittent Loss of Cruise Control
- Accumulator - Intermittent DTC's 36, 52, or 54 Set
- Keyless Entry Transmitter - Will Not Unlock Doors
- Front Coil Spring - Creak/Pop, Or Squeak
- Sunroof Sunshade - Binding Or Coming Out Of The Track
- Door Trim Defroster Garnish - Cracked
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 232496 - 04/12/96
- 21-18-96 - 12/27/96
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Rear Strut - Knocking or Tapping Noises
- Electrical - Wire Splice Procedure Revision
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- A/T - Vehicle Shudder During Torque Converter Operation
- A/T Pan Gasket - Reusable Design
- A/T - Intermittent MIL ON/DTC's Set/Shift Concerns
- TCM - Limp In Mode Tendency Reduction
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- OBDII - Readiness Code Retention
- PCM - Flash Programming Failure Recovery
- A/T - Fluid Usage
- A/T - Vehicle Shudder During TC Lock-up
- A/T - ATF Usage List
- Spark Plug - Intermittent Single Cylinder Misfire/MIL On
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Service Manual - Update
- Brakes - Noise Explanation
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Recall 96V158002: Fuel Pump/Gauge Unit Gasket Leak
- Fuel Pump/Sender - Installation Precautions
- Brakes - Pulsation/Shudder
- Spark Plugs - Hard Start/Misfire Or Rough Idle
- Aluminum Engine - Gasket Surface Preparation
- Recall - Lower Lateral Arm Ball Joint Boots
- Recall 99V066003: Lower Ball Joint Separation
- Recall 00V421002: Lower Lateral Arm Ball Joint Wear
- Rear Shock - Thump/Chuckle or Creak Noise
- Tire and Wheel - Runout
- Front Suspension - Knocking, Clunking Noise
- Door Panel/Speaker - Buzz and Rattle
- Sunroof - Ratcheting Sound or Jerky Operation
- Recall - Transfer Case Oil Leak
- Recall 98V069002: Transfer Case Lockup
- A/T - 41TE/42LE Shudder During EMCC Shift
- Converter Clutch - Vehicle Shudder on Lock Up
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Ratcheting Sound When Coming To Stop
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- PCM - O2 Sensor Faults/MIL ON
- Engine Controls - Flash Programming Failure Recovery
- Purge Solenoid - Ticking Noise at Idle
- A/T - Shudder on 1 - 2/2 - 3 Upshift
- A/T - MIL ON/DTC's Set
- Power Seat Switch - Sticks
- Power Seat - New Motor Replacement Procedures
- Theft Alarm - Intermittent/Random Activation
- Door Ajar Lamp/Dome Lamp - Intermittent Operation
- Radio Communication Equipment - Recommendations
- Airbag/Clock Spring - Service
- Recall - Fuel Tank Leak
- Recall 94V149001: ABS Hydraulic Unit Attachment Failure
- Brakes - Bendix ABX 4 ABS System Test Revisions
- Black Plastic Body Components - Chalky Residue
- Recall - Passenger Air Bag Safety
- Emissions/Engine Controls - Service Manual Revisions
- Auto Computers - Y2K Effects
- Generic Scan Tool - Reference Information
- Engine Controls - 'No Start' Test Revisions
- Engine Controls/Fuel System - DTC's/Lean Test Revision
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Rear Quarter Trim - Buzz or Rattle
- Door - Popping/Rattle/Squeak
- Sunroof - Inoperative/Opens By Itself
- Wipers/Washers - Wipers Smear or Streak Windshield
- Windshield Washer Nozzles - Fluid Leaks
- Engine - Coolant Recommendations
- A/T - Intermittent 2nd Gear and Reverse Only After Start
- A/T - (41TE/42LE) Service Information
- A/T - 41TE/42LE Interactive Cruise Control
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - CD Compatibility
- A/T - ATF+4 Fluid Usage/Applications
- Front Suspension/Alignment - Vehicle Drift or Lead
- Transmission Range Sensor - Production Change
- Rear Trailing Arm - Squeaking or Rubbing Sound
- Ignition Key - Difficult to Remove From Cylinder
- Speed Sensor - Intermittent Loss of Cruise Control
- Wiring - Revised Splicing Procedure
- Speed Control - Adaptive Strategy
- Remote Keyless Entry - Programming Information
- Door Glass - Adjustment Procedures
- Windows - Interior Film Build Up
- Recall 96V158000: Fuel Pump/Fuel Gauge Unit Gasket Leak
- Accumulator - Intermittent DTC's 36, 52, or 54 Set
- Keyless Entry Transmitter - Will Not Unlock Doors
- Garage Door Opener - Rolling Code Information
- Front Coil Spring - Creak/Pop, Or Squeak
- Sunroof Sunshade - Binding Or Coming Out Of The Track
- Door Trim Defroster Garnish - Cracked
- Engine - High Driveability Index Fuels
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- A/T Pan Gasket - Reusable Design/Installation
- A/T - ATF + 4 Fluid Usage
- A/T - Repair/Replacement Guidelines
- Restraints - Child Seat Tether Installation
- Recall - Replace Mopar(R) Value Line Catalytic Converter
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process