Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Low or No Cabin Heat/Engine Overheat
- Front Brakes - Metallic Knock on Bumps
- Heater, A/C Housing - Water Ingestion
- Defrost Ducts - Do Not Defrost The Bottom Of Windshield
- Heater, A/C Housing - Debris Build Up
- Front Suspension - Squeak Or Creak Noises
- Rear Suspension - Squeak/Noise
- Steering - Loose Feel/Clunking on Turns
- Steering Gear - Cold Squawk Noise
- Suspension/Alignment - Vehicle Pull Diagnosis
- Rear Coil Spring - Excessive Road Noise
- Polycast Wheel - Center Cap Falls Off
- Front Suspension - Clunking or Rattling Noise
- Front Seat Cushion Pan - Cracked/Welds Broken
- Body Mounted Door Weatherstrip - Loose
- Front Hub - Clunk/Click Noise
- A/T - Shudders During Upshift With No DTC's Present
- Converter Clutch - Vehicle Shudder on Lock Up
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Burned Fluid/Damaged Internal Components
- A/T Cooler Lines - Fluid Leaks at Crimp Connection
- PCM/BCM - No Start or Erratic Theft Alarm Operation
- Oxygen Sensor - MIL ON With Hex Code $3E or $42
- ABS - Warning Lamp ON Intermittently
- A/T - Poor Shift Quality
- TCM - Improved Transmission Shift Quality
- Passenger Airbag Door - Poor Fit/Warped
- Airbag Lamp ON/Multiple System Faults
- Fuel Gauge - Erratic Readings
- A/C Suction Line - Failure
- Front Suspension - `Squawk' Noise When Cold
- Steering Wheel - Creaking/Clicking Noise
- Black Plastic Body Components - Chalky Residue
- Trunk - Water and Dust Leaks
- Backlight/Windshield Moulding - Glue Oozing Out
- Wipers/Washers - Wipers Smear or Streak Windshield
- Windshield Washer Nozzle - Freeze Up
- Windshield Washer Nozzle - Freeze-Up
- Power Steering Pressure Hose - Whine Noise
- A/T - Shudder/Bumps/Slippage
- A/T - Transaxle Limp In Condition
- RAY Radio - Slow or Erratic Tape Operation
- A/C System - Intermittently or Totally Inoperative
- Park/Turn Lamps - Moisture Buildup Inside
- Differential Vent - Leaks Fluid
- Door Check Straps - Snapping Noise When Cold
- A/C Evaporator - Emits Odors
- A/C - Musty Odors When Hot/Humid
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 240695 - 05/05/95
- 235296 - 08/30/96
- 211196 - 07/19/96
- 21-18-96 - 12/27/96
- 19-03-97 - 02/14/97
- 084094 - 08/05/94
- 081595 - 04/07/95
- Windshield Washer Nozzle - Freezes Up
- Headlamp - Pattern Improvement
- Cruise Control - Erratic During Initial Speed Set
- Trunk - Water Leak
- Door Check Straps - Snapping Noise
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Airbag - ON/OFF Switches Availability
- Heater/AC Housing - Water Ingestion
- Steering Wheel - Loose Feel or Clunk
- Inner Tie Rod - Loose Steering
- Steering Wheel - Loose Feel/Clunk
- Steering/Suspension - Pull to The Right
- Electrical - Wire Splice Procedure Revision
- Differential Vent - Fluid Leaks
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- A/T - Vehicle Shudder During Torque Converter Operation
- A/T - Poor Shifting Quality
- A/T - Fluid Burned/Internal Damage
- A/T - Vehicle Shudder During T/C Lock-up
- TCM - 41TE or 42LE A/T, Poor Shift Quality/Shudder
- Engine Controls - Flash Reprogramming Failure
- PCM - Flash Programming Failure Recovery
- Cooling System - Overheating/Fill Procedure
- Engine - Camshaft/Bearing Service
- A/T - Fluid Usage
- A/C - Musty Odors When Hot or Humid
- Front Strut - Vehicle Drifts/Leads
- Alignment - Vehicle Leads or Pulls.
- A/T - Vehicle Shudder During TC Lock-up
- A/T - 41TE/42LE Intermittent Delayed Engagement
- A/T - ATF Usage List
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Service Manual - Revisions
- Service Manual - Revisions / Updates
- Service Manual - Revision
- Service Manual - Revisions and Updates
- Service and/or Diagnostic Manual - Revision Descriptions
- Brakes - Noise Explanation
- A/C Performance - Diagnostic Procedure
- Climate Control Diagnostics - Revision
- A/C - Low or No Cabin Heat/Engine Overheat
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- A/C - Diagnostics Text Correction
- Engine - Oil Leak Prevention/Diagnosis
- Ignition/Steering - Service Manual Revisions
- Front Brakes - Metallic Knock on Bumps
- Spark Plug - Update for Improved Cold Start
- Heater, A/C Housing - Water Ingestion
- Defrost Ducts - Do Not Defrost The Bottom Of Windshield
- Instrument Panel Vents - Emit White Flakes
- Heater, A/C Housing - Debris Build Up
- Front Suspension - Squeak Or Creak Noises
- Rear Suspension - Squeak/Noise
- Steering - Loose Feel/Clunking on Turns
- Steering Gear - Cold Squawk Noise
- Suspension/Alignment - Vehicle Pull Diagnosis
- Inner Tie Rod End To Steering Gear - Service Torque
- Engine - Camshaft/Bearing Inspection/Service
- Aluminum Engine - Gasket Surface Preparation
- Rear Coil Spring - Excessive Road Noise
- Tire and Wheel - Runout
- Polycast Wheel - Center Cap Falls Off
- Front Suspension - Clunking or Rattling Noise
- Front Seat Cushion Pan - Cracked/Welds Broken
- Body Mounted Door Weatherstrip - Loose
- Front Hub - Clunk/Click Noise
- A/T - 41TE/42LE Shudder During EMCC Shift
- A/T - Shudders During Upshift With No DTC's Present
- Converter Clutch - Vehicle Shudder on Lock Up
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Burned Fluid/Damaged Internal Components
- A/T Cooler Lines - Fluid Leaks at Crimp Connection
- PCM/BCM - No Start or Erratic Theft Alarm Operation
- Oxygen Sensor - MIL ON With Hex Code $3E or $42
- Front Axle - Hub Nut Torque Revision
- Drivetrain - Front Hub Nut Torque Revisions
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- ABS - Warning Lamp ON Intermittently
- ABS Control Module - Service Precaution
- Engine Controls - Flash Programming Failure Recovery
- A/T - Poor Shift Quality
- TCM - Improved Transmission Shift Quality
- Radio Communication Equipment - Recommendations
- Passenger Airbag Door - Poor Fit/Warped
- Airbag/Clock Spring - Service
- Airbag Lamp ON/Multiple System Faults
- Front Brake Rotor - Service
- Fuel Gauge - Erratic Readings
- Headlamp Pattern - Improvement
- A/C Suction Line - Failure
- ABS - Service Manual Updates
- Brakes - Bendix ABX 4 ABS System Test Revisions
- ABS System - Diagnostic Procedure Revision
- Front Suspension - `Squawk' Noise When Cold
- Steering Wheel - Creaking/Clicking Noise
- Black Plastic Body Components - Chalky Residue
- Radio Transmitters - Installation
- Recall - Passenger Air Bag Safety
- Airbag - NHTSA Authorized Deactivation
- Air Bag System - Diagnostic Procedures Revisions
- Auto Computers - Y2K Effects
- Electrical - Pin Out and Graphics Revisions
- Electrical - Connectors/Wiring Circuit Revisions
- Trunk - Water and Dust Leaks
- Backlight/Windshield Moulding - Glue Oozing Out
- Door Glass Lift Plate - Service/Replacement
- Wipers/Washers - Wipers Smear or Streak Windshield
- Windshield Washer Nozzle - Freeze Up
- Windshield Washer Nozzle - Freeze-Up
- Cup Holder - Improvements/Service
- Engine - Coolant Recommendations
- Power Steering Pressure Hose - Whine Noise
- A/T - Shudder/Bumps/Slippage
- A/T - 41TE/42LE Cruise Control Interaction
- A/T - 41TE/42LE Interactive Cruise Control
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Electrical Harness Repair Parts
- A/T - 41TE/42LE Bind-Up In Reverse
- A/T - 41TE/42LE Lock-Up Control System Changes
- A/T - 41TE/42LE DTC 41, 42, 43, or 44/Solenoid Circuit
- A/T - 41TE/42LE 2/4 Accumulator Piston Replacement
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - CD Compatibility
- Recall - Lower Control Arm Reinforcement
- Recall 99V215000: Cracked Lower Control Arm Brackets
- Transmission Range Sensor - Production Change
- A/T - Transaxle Limp In Condition
- RAY Radio - Slow or Erratic Tape Operation
- Engine - Oil Leak Diagnosis
- Charging System - No Code test Procedure Revisions
- Wiring - Revised Splicing Procedure
- Wiring Diagram - Service Manual Revisions
- Cooling System - Cooling Fan Circuit Revisions
- Speed Control - Adaptive Strategy
- Remote Keyless Entry - Operation
- Windows - Interior Film Build Up
- A/C System - Intermittently or Totally Inoperative
- Recall 04V021000: Shift Interlock Failure
- Recall - A/T Shifter Ignition/Park Interlock Defect
- Park/Turn Lamps - Moisture Buildup Inside
- Heating/Air Conditioning Housing - Service
- Emergency Trunk Release - Availability
- Differential Vent - Leaks Fluid
- R 134A Refrigerant - Leak Detection
- Door Check Straps - Snapping Noise When Cold
- A/C Evaporator - Emits Odors
- Steering Gear - Mounting Bushing Service
- Steering - Power Steering Fluid Usage
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- A/T Pan Gasket - Reusable Design/Installation
- A/C - Musty Odors When Hot/Humid
- A/T - ATF + 4 Fluid Usage
- Restraints - Child Seat Tether Installation
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process