Heater AC Housing - Leaks Water to Interior
NO.: 24-19-93GROUP: Heating & A/C
DATE: Jul. 16, 1993
SUBJECT:
Heater/AC Housing Water Ingestion
MODELS:
1993 (LH) Concorde/Intrepid/Vision
1994 (LH) LHS/New Yorker
SYMPTOM/CONDITION:
Water entering the vehicle interior at the base of the instrument panel on the passenger side, and/or droplets exiting the panel outlets during heavy rain or car wash.
REPAIR PROCEDURE:
This bulletin involves enlarging the right plenum drain hole.
1. Raise the vehicle on a suitable hoist.
2. Remove the two rear-most screws from the right front plastic wheel house splash shield and pull down to allow access to the plenum drain hole.
3. Enlarge the drain hole 20 mm toward the front of the vehicle, as indicated, using a suitable metal cuffing tool (die grinder, air chisel).
4. Apply Mopar touch-up paint or equivalent sealer to any exposed bare metal.
5. Install the wheel house splash shield.
POLICY:
Reimbursable within the provisions of the warranty.
TIME ALLOWANCE:
Labor Operation No. 24-65-41-91 0.3 Hrs.
FAILURE CODE: XX - Service Adjustment