Cooling System - Fan ON Continuously/Overheats: Overview

NO: 07-04-98

GROUP: Cooling

DATE: Apr. 17, 1998

SUBJECT:
Vehicle Overheats (Radiator Fan Inoperative) Or Radiator Fan Runs Continuously

THIS BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 07-07-97 DATED FEBRUARY 20, 1998 WHICH SHOULD BE NOTED IN THE 1997 TECHNICAL SERVICE BULLETIN MANUAL (PUBLICATION NUMBER 81-699-98004). THE REVISION PROVIDES A NEW PART NUMBER FOR THE RADIATOR FAN RELAY. THE CHANGE IS HIGHLIGHTED WITH ASTERISKS.

MODELS:
1997 - 1998 (PL) Neon

NOTE:
THIS BULLETIN APPLIES TO VEHICLES BUILT AT TOLUCA ASSEMBLY PRIOR TO SEPTEMBER 11, 1997 (MDH 0911XX). TOLUCA ASSEMBLY IS DESIGNATED BY A "T" IN THE ELEVENTH POSITION OF THE VEHICLE IDENTIFICATION NUMBER.

SYMPTOM/CONDITION:

Vehicle overheats or radiator fan continues to run.

DIAGNOSIS:

Actuate the radiator fan relay using the DRB III. If the radiator fan does not come on or fan runs continuously, perform the Repair Procedure.

PARTS REQUIRED:

1 05293157AA Jumper Wire With Diode, Radiator Fan
**1 04707286 Relay, Radiator Fan**
2 06015756 Tie Strap

POLICY: Reimbursable within the provisions of the warranty.

TIME ALLOWANCE:

Labor Operation No: 08-65-12-92 0.3 Hrs.

FAILURE CODE: P8 - New Part