M/T - 5-Speed Revision

84chrysler2

Models


1984 Conquest, Ram 50 & Power Ram 50 Equipped With KM132/KM145 Manual Transmission


Subject


5-Speed Manual Transmission Revisions


Index


TRANSMISSION

Date

August 20, 1984


No.


21-06-84 REVISION A

P-3516-C
The model designation section on page 1 of Technical Service Bulletin

#21-06-84 incorrectly reads "Challenger, Sapporo passenger cars".

The affected car model is "Conquest". Please insert this revision in your 1984 service bulletin binder and discard the original bulletin.


The KM132/KM145 transmissions were revised during the 1984 model year (from September, 1983) to improve the engagement of reverse gear. As a result of these changes, the parts indicated in the attached list on page 2 are not interchangeable. The correct parts can be specified by checking the transmission number stamped in the upper left corner of the bell housing. The service procedure for the "Up To" and "After" transmissions remain the same.


POLICY: Information only

AFTER TRANS #CB6452 UP TO TRANS #CB6452

NO. PART NAME KM132 KM145 KM132 KM145

1. RETAINER, Rear Brg. MD713602 MD713602 MD703800 MD703800
2. SCREW MF201595 MF201595 --- ---
BOLT (with washer) --- --- MD700758 MD700758
3. MAINSHAFT MD715581 MD713668 MD703761 MD704170
4. SPACER MD703731 MD703731 MD703732 MD703732
5. GEAR, Reverse MD715768 MD715768 --- ---
6. BEARING, Needle MD713674 MD713674 --- ---
7. SLEEVE, Rev. Gear MD713673 MD713673 --- ---
Brg.
8. PLATE, Stop --- --- MD703809 MD703809
9. HUB, Synchronizer MD716397 MD716397 MD703957 MD703957
10. SLEEVE, Synchronizer MD716397 MD716397 MD703957 MD703957
11. KEY, Synchronizer MD701766 MD701766 MD701810 MD701810
12. SPACER MD712954 MD714386 MD703784 MD703723
13. GEAR, Counter/S MD715769 MD715769 MD703772 MD703772
Reverse
14. SPACER MD714823 MD714823 MD703724 MD703724
15. SHAFT, Rev. Idler MD714821 MD714821 MD703697 MD703697
Gear
16. SCREW MF201595 MF201595 --- ---
BOLT --- --- MD700758 MD700758
17. GEAR, Rev. Idler MD715770 MD715770 MD703771 MD703771
18. BEARING, Needle MD712965 MD712965 MD701748 MD701748
(2 pcs.) (2 pcs.)
19. WASHER, Thrust MD714388 MD714388 MD705738 MD705738
20. NUT MF431107 MF431107 MF431105 MF431105
21. PIN, Split MF472085 MF472085 MG103373 MG103373
22. SHIFT RAIL, Assy. MD714825 MD715794 MD703866 MD713812