A/T - Whining Sound Between 68 MPH and 84 MPH
NUMBER: 21-003-05GROUP: Transmission
DATE: January 19, 2005
SUBJECT:
Transfer Gear Whine Sound Between 68 mph and 84 mph, Either Accelerating or Decelerating
OVERVIEW:
This bulletin involves inspecting and properly seating the lower steering column boot.
MODELS:
2003 - 2005 (JR) Sebring Convertible/Sebring Sedan/Stratus Sedan
NOTE:
This bulletin applies to vehicles equipped with an automatic transmission (sales code DGB or DGL).
SYMPTOM/CONDITION:
Vehicle operator may experience a transfer gear whine sound while vehicle is either accelerating or coasting down between 68 mph (109 kph) and 84 mph (135 kph). This condition may also be described as a whistling sound.
REPAIR PROCEDURE:
1. Raise Vehicle on a hoist.
2. Inspect the lower steering column boot to see if it is sealed properly against the bulkhead. The lower steering column boot should be pressed against the bulkhead (Fig. 1). If the lower steering column boot is installed properly further diagnosis is required. If lower steering column boot is not installed properly continue to Step # 3.
3. Lower vehicle.
4. Pull back carpet from around lower steering column boot.
5. Using a rubber mallet, tap boot on the perimeter until all six (6) clips are seated.
6. Re-install carpeting.
POLICY:
Reimbursable within the provisions of the warranty.
TIME ALLOWANCE:
FAILURE CODE:
Disclaimer:
This bulletin is supplied as technical information only and is not an authorization for repair.