Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Body - Light To Moderate Paint Imperfections
- Instruments - Brightness Changes in Illumination
- A/C - Low or No Cabin Heat/Engine Overheat
- Suspension - Squeaking Sound from Rear Strut(s)
- Engine Controls - Erroneous MIL/DTC's
- Body - Windows Creak/Shudder/Chatter When Closing
- Body - Wind Noise From Sunroof or B-Pillar Area
- Interior - Headliner Sags/Rattles at Rear
- A/T - Delayed Gear Engagement/Possible DTC's
- Engine - No Start/Limp In Mode/Misfire/DTC's Set
- PCM - MIL ON/MAP Sensor DTC Set
- Engine Controls - MIL ON/False DTC's Set
- Audio System - Distorted Output/Door Panel Buzz/Rattle
- Door (Front) - Snapping Sound when Opening or Closing
- Wipers/Washers - Wipers Smear or Streak Windshield
- Audio System - 'CD ERR' Message Displayed
- Fuel System - Difficult Fuel Filler Cap Removal
- A/C - Erratic Operation/Poor Performance
- Fuel System - Fuel Tank Slow to Fill
- Body - Power Sun Roof Inoperative
- Interior - Wooden Trim Panels Scratched
- Window Opening Molding - Hazy/Discolored
- Body - Window Molding Discoloration
- A/C - Musty Odors When Hot/Humid
- A/T - MIL ON, DTC P1776 Set
- Engine Oil Pressure Light - ON/Flickers
- Superceded Bulletins
- 18-007-03B - 07/25/03
- 18-007-03A - 07/04/03
- 18-007-03 - 03/14/03
- 08-010-02 - 07/22/02
- Body - Front Window Chatter/Squeak/Shudder When Closing
- Outside Rearview Mirror Glass - Replacement
- Interior - Wooden Trim Panel Scratches
- Body - Window Surround Molding Discoloration
- Interior - Front Door Handle/Bezel Replacement
- A/C - Poor Performance/Erratic Operation
- A/C - Erratic Operation/DTC's Stored
- Suspension - Rear Strut Squeaking Sound
- A/T - Diagnostic Teardown Procedures
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- A/T - MIL ON/DTC P1776 Set
- Fuel Cap - Difficult To Remove
- Engine Control - Generic PCM Programming Procedure
- Engine Controls - Generic PCM Programming
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Generic PCM Programming Procedure
- Engine Controls - Co-Pilot Support/Cable Selection
- Engine Controls - PCM Initialization Procedure
- Engine Controls - PCM Initialization After Replacement
- Engine Controls - Programming a Generic PCM
- Power Steering - New Fluid Type
- A/T - Fluid Usage
- A/C - Erratic Operation
- A/C - Musty Odors When Hot or Humid
- Chrome Wheels - Care/Maintenance
- Chrome Wheels - Care and Maintenance
- Wheels - Chrome Wheel Care
- A/T - ATF Usage List
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Body - Light To Moderate Paint Imperfections
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Instruments - Brightness Changes in Illumination
- A/C - Low or No Cabin Heat/Engine Overheat
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Suspension - Squeaking Sound from Rear Strut(s)
- Cylinder Head - Oil Gallery Cup Plug Service
- Engine Controls - Erroneous MIL/DTC's
- Wheels - Caring for Chrome Wheels
- Body - Windows Creak/Shudder/Chatter When Closing
- Body - Wind Noise From Sunroof or B-Pillar Area
- Interior - Headliner Sags/Rattles at Rear
- A/T - Delayed Gear Engagement/Possible DTC's
- Engine - No Start/Limp In Mode/Misfire/DTC's Set
- Ignition - Do Not Crank Engine With Open Secondary
- Freeze Frame Data - Displays Incorrectly On Scanner
- PCM - MIL ON/MAP Sensor DTC Set
- Engine Controls - MIL ON/False DTC's Set
- Engine Controls - Flash Programming Failure Recovery
- Radio - Caution: Locking Antenna Collar
- Airbag/Clock Spring - Service
- Driver Airbag - Trim Cover Service
- Safety Systems - Inadvertent Damage/Disabling
- Electrical - Radio Equipment Installation Recommendation
- Safety Systems - Vehicle Modifications/Repair
- Generic Scan Tool - Reference Information
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Audio System - Distorted Output/Door Panel Buzz/Rattle
- Campaign - Front Door Speaker Wiring
- Interior - Front Door Handle or Bezel Replacement
- Door (Front) - Snapping Sound when Opening or Closing
- Wipers/Washers - Wipers Smear or Streak Windshield
- Outside Rearview Mirror - Glass Replacement
- Audio System - 'CD ERR' Message Displayed
- A/T - ATF+4 Fluid Usage/Applications
- A/T - 41TE/42LE Torque Converter Clutch Break-In
- Fuel System - Difficult Fuel Filler Cap Removal
- A/C - Erratic Operation/Poor Performance
- Keyless Entry - Programming Procedure
- Interior - Wood Trim Scratch Repair
- Fuel System - Fuel Tank Slow to Fill
- Steering - Power Steering Fluid Usage
- Body - Power Sun Roof Inoperative
- Interior - Wooden Trim Panels Scratched
- Recall 03V035000: Seat Back Recliner Bolt Breakage
- Recall - Driver's Seat Recliner Bolts
- Window Opening Molding - Hazy/Discolored
- Body - Window Molding Discoloration
- A/C - Musty Odors When Hot/Humid
- Engine Control - PCM Initialization Procedure
- Engine Controls - Programming Generic PCMs
- A/T - ATF + 4 Fluid Usage
- A/T - Repair/Replacement Guidelines
- Body - Paint Overspray Removal Procedures
- A/T - MIL ON, DTC P1776 Set
- Engine Oil Pressure Light - ON/Flickers
- Paint - Clearcoat Blending During Refinish Process