Fuel System - MIL ON DTC Set/Driveability Concerns: Overview

NUMBER: 08-35-99

GROUP: Electrical

DATE: Oct. 8, 1999

SUBJECT:
MIL Illumination, Leak Detection Pump DTC and/or Fuel Gauge Inaccurate

OVERVIEW:
This bulletin involves replacing the inline fuel tank to left body harness connector with a sealed connector.

MODELS:
1998 - 1999 (LH) Concorde/Intrepid/LHS/3OOM

SYMPTOM/CONDITION:
MIL illumination with Leak Detection Pump (LDP) Diagnostic Trouble Code (DTC), fuel gauge reading inaccurate, fuel pump not working, and/or engine run-on.

DIAGNOSIS:
Using the Mopar Diagnostic System (MDS2) and/or the Diagnostic Scan Tool (DRB III) with the appropriate Diagnostic Procedures Manual, verify all engine/transmission systems are functioning as designed. If non-LDP related DTC's are present, record them on the repair order and repair as necessary before proceeding further with this bulletin. If Leak Detection Pump DTC's are present, and/or owner describes an inaccurate fuel gauge or engine run-on, inspect the C308 wire connector located under the rear seat cushion for the presence of moisture and/or corrosion. If moisture/corrosion exist, perform the Repair Procedure.

PARTS REQUIRED:

1 05013984AA Insulator/Terminal Repair Kit
1 05013988AA Insulator/Terminal Repair Kit
12 04778570 Heat Shrink Tubing

POLICY: Reimbursable within the provisions of the warranty.

TIME ALLOWANCE:

Labor Operation No: 08-90-73-90 0.8 Hrs.

FAILURE CODE: P8 - New Part