Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Low or No Cabin Heat/Engine Overheat
- Front Brakes - Metallic Knock on Bumps
- Heater, A/C Housing - Water Ingestion
- Heater, A/C Housing - Debris Build Up
- Steering - Loose Feel/Clunking on Turns
- Steering Gear - Cold Squawk Noise
- Suspension/Alignment - Vehicle Pull Diagnosis
- Front Suspension - Clunking or Rattling Noise
- Front Seat Cushion Pan - Cracked/Welds Broken
- Body Mounted Door Weatherstrip - Loose
- A/T - Shudders During Upshift With No DTC's Present
- Converter Clutch - Vehicle Shudder on Lock Up
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Burned Fluid/Damaged Internal Components
- A/T Cooler Lines - Fluid Leaks at Crimp Connection
- PCM - OBDII Readiness Code Retention
- Oxygen Sensor - MIL ON With Hex Code $3E or $42
- PCM - Multiple Driveability Concerns
- Erroneous MIL ON with Hex Code $6A Set
- PCM - Erroneous EGR System Codes Set
- PCM - Erroneous Misfire DTC
- I/M Testing - OBDII CARB Readiness Monitor Information
- A/T - Shudder on 1 - 2/2 - 3 Upshift
- A/T - MIL ON/DTC's Set
- Radio - Amplified Generator Whine at Low Volume
- Passenger Airbag Door - Poor Fit/Warped
- Engine Dipstick/Tube - Rust/Sticking
- Engine Oil Level Indicator - Handle Broken or Cracked
- A/C Suction Line - Failure
- Black Plastic Body Components - Chalky Residue
- Speakers - Intermittent Popping Noise
- Trunk - Water and Dust Leaks
- Passenger Side Windshield Wiper - Streaking
- Wipers/Washers - Wipers Smear or Streak Windshield
- Windshield Washer - Sprays Too Low at High Speeds
- Speed Sensor - Intermittent Loss of Cruise Control
- Accumulator - Intermittent DTC's 36, 52, or 54 Set
- Suspension/Frame - Popping or Metallic Noises
- Differential Vent - Leaks Fluid
- Door Check Straps - Snapping Noise When Cold
- A/C Evaporator - Emits Odors
- Rear Brakes - Ticking Noise
- Sunroof Sunshade - Sticking/Binding
- A/C - Musty Odors When Hot/Humid
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 235296 - 08/30/96
- 23-11-95 - 03/10/95
- 211196 - 07/19/96
- 21-18-96 - 12/27/96
- 19-03-97 - 02/14/97
- Sunroof Sunshade - Binding
- Trunk - Water Leak
- Door Check Straps - Snapping Noise
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Airbag - ON/OFF Switches Availability
- Steering Wheel - Loose Feel or Clunk
- Inner Tie Rod - Loose Steering
- Steering Wheel - Loose Feel/Clunk
- Steering/Suspension - Pull to The Right
- Electrical - Wire Splice Procedure Revision
- Differential Vent - Fluid Leaks
- A/T - Diagnostic Teardown Procedures
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- A/T - Vehicle Shudder During Torque Converter Operation
- A/T - Fluid Burned/Internal Damage
- A/T - Intermittent MIL ON/DTC's Set/Shift Concerns
- TCM - Limp In Mode Tendency Reduction
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- OBDII - Readiness Code Retention
- PCM - Flash Programming Failure Recovery
- Cooling System - Overheating/Fill Procedure
- Engine - Camshaft/Bearing Service
- A/T - Fluid Usage
- A/C - Musty Odors When Hot or Humid
- Alignment - Vehicle Leads or Pulls.
- A/T - Vehicle Shudder During TC Lock-up
- A/T - ATF Usage List
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Service Manual - Changes and Revisions
- Service Manual - Revisions
- Brakes - Noise Explanation
- A/C Performance - Diagnostic Procedure
- A/C - Low or No Cabin Heat/Engine Overheat
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Engine - Oil Leak Prevention/Diagnosis
- Ignition/Steering - Service Manual Revisions
- Front Brakes - Metallic Knock on Bumps
- Heater, A/C Housing - Water Ingestion
- Heater, A/C Housing - Debris Build Up
- Steering - Loose Feel/Clunking on Turns
- Steering Gear - Cold Squawk Noise
- Suspension/Alignment - Vehicle Pull Diagnosis
- Inner Tie Rod End To Steering Gear - Service Torque
- Engine - Camshaft/Bearing Inspection/Service
- Aluminum Engine - Gasket Surface Preparation
- Ambient Air Temperature Sensor - Service
- Tire and Wheel - Runout
- Front Suspension - Clunking or Rattling Noise
- Front Seat Cushion Pan - Cracked/Welds Broken
- Body Mounted Door Weatherstrip - Loose
- A/T - 41TE/42LE Shudder During EMCC Shift
- A/T - Shudders During Upshift With No DTC's Present
- Converter Clutch - Vehicle Shudder on Lock Up
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Burned Fluid/Damaged Internal Components
- A/T Cooler Lines - Fluid Leaks at Crimp Connection
- Engine Controls/Emissions - Manual Revisions
- PCM - OBDII Readiness Code Retention
- Engine Controls - PCM Wiring Update
- Oxygen Sensor - MIL ON With Hex Code $3E or $42
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- PCM - Multiple Driveability Concerns
- Recall - Reprogram (flash) PCM
- Erroneous MIL ON with Hex Code $6A Set
- PCM - Erroneous EGR System Codes Set
- PCM - Erroneous Misfire DTC
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine Controls - Flash Programming Failure Recovery
- A/T - Shudder on 1 - 2/2 - 3 Upshift
- A/T - MIL ON/DTC's Set
- Radio - Amplified Generator Whine at Low Volume
- Radio Communication Equipment - Recommendations
- Passenger Airbag Door - Poor Fit/Warped
- Airbag/Clock Spring - Service
- Engine Dipstick/Tube - Rust/Sticking
- Engine Oil Level Indicator - Handle Broken or Cracked
- Ignition System - Secondary Ignition Test Revision
- A/C Suction Line - Failure
- Brakes - Bendix ABX 4 ABS System Test Revisions
- Black Plastic Body Components - Chalky Residue
- Radio Transmitters - Installation
- Recall - Passenger Air Bag Safety
- Airbag - NHTSA Authorized Deactivation
- Emissions/Engine Controls - Service Manual Revisions
- Auto Computers - Y2K Effects
- Generic Scan Tool - Reference Information
- Engine Controls - 'No Start' Test Revisions
- Engine Controls/Fuel System - DTC's/Lean Test Revision
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Speakers - Intermittent Popping Noise
- Trunk - Water and Dust Leaks
- Door Glass Lift Plate - Service
- Passenger Side Windshield Wiper - Streaking
- Wipers/Washers - Wipers Smear or Streak Windshield
- Windshield Washer - Sprays Too Low at High Speeds
- Cup Holder - Improvements/Service
- Engine - Coolant Recommendations
- A/T - Intermittent 2nd Gear and Reverse Only After Start
- A/T - (41TE/42LE) Service Information
- A/T - 41TE/42LE Interactive Cruise Control
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - 41TE (A604), 42LE Overdrive Clutch Hub/Improved
- A/T - 41TE/42LE Lock-Up Control System Changes
- A/T - 41TE/42LE 2/4 Accumulator Piston Replacement
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - CD Compatibility
- A/T - ATF+4 Fluid Usage/Applications
- Transmission Range Sensor - Production Change
- Speed Sensor - Intermittent Loss of Cruise Control
- Wiring - Revised Splicing Procedure
- Cooling System - Cooling Fan Circuit Revisions
- Speed Control - Adaptive Strategy
- Windows - Interior Film Build Up
- Recall 04V021000: Shift Interlock Failure
- Recall - A/T Shifter Ignition/Park Interlock Defect
- Heating/Air Conditioning Housing - Service
- Accumulator - Intermittent DTC's 36, 52, or 54 Set
- Suspension/Frame - Popping or Metallic Noises
- Emergency Trunk Release - Availability
- Differential Vent - Leaks Fluid
- Door Check Straps - Snapping Noise When Cold
- A/C Evaporator - Emits Odors
- Steering Gear - Mounting Bushing Service
- Steering - Power Steering Fluid Usage
- Rear Brakes - Ticking Noise
- Engine - High Driveability Index Fuels
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- Sunroof Sunshade - Sticking/Binding
- A/T Pan Gasket - Reusable Design/Installation
- A/C - Musty Odors When Hot/Humid
- A/T - ATF + 4 Fluid Usage
- A/T - Repair/Replacement Guidelines
- Restraints - Child Seat Tether Installation
- Recall - Replace Mopar(R) Value Line Catalytic Converter
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process