Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Safety
- Recall 96V006000: Oil Gallery Plug Leaks Engine Oil
- Recall 97V201000: Control Arm/Ball Joint Separation
- Recall 96V075000: Brake Master Cylinder Leak
- Recall - Master Cylinder Primary Piston
- Recall - ABS Master Cyl. Piston/Hydraulic Control Unit
- Recall - Passenger Air Bag Safety
- Recall 97V095000: Secondary Hood Latch Spring Revised
- Recall - Front Lower Control Arm Ball Joints
- Recall - Engine Oil Galley Plugs
- Recall - Hood Latch Spring
- Recall 98V183000: Ignition-Park Interlock System Fault
- Recall 04V021000: Shift Interlock Failure
- Recall - A/T Shifter Ignition/Park Interlock Defect
- Recall 96V074000: ABS Hydraulic Control Unit Corrosion
- Customer Interest
- Front Brakes - Grinding or Squeaking Noise
- A/C Compressor - Failure/Performance Concerns
- Steering Gear - Whistle/Hiss On Right Turns
- Engine - Timing Belt Frayed/Shredded/Broken
- A/C System - Performance Complaints
- Steering Wheel/Steering Column - Clunking Or Rattle
- A/T - Shudders During Upshift With No DTC's Present
- Converter Clutch - Vehicle Shudder on Lock Up
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Fluid is Burned/Internal Damage
- A/T - Ratcheting Sound When Coming To Stop
- PCM - OBDII Readiness Code Retention
- MIL ON, Hex Code $3E, Sag/Hesitation/Rough Idle
- Windshield Wiper - Delay Intervals Erratic
- PCM - MIL ON/DTC's Set/Driveability Concerns
- PCM - Erroneous EGR System Codes Set
- I/M Testing - OBDII CARB Readiness Monitor Information
- Air Filter Element Seal - Torn
- A/T - Shudder on 1 - 2/2 - 3 Upshift
- A/T - MIL ON/DTC's Set
- A/C - EBL Indicator Bulb Does Not Light
- Tie Rod End - Intermittent Popping Noise
- Black Plastic Body Components - Chalky Residue
- B Pillar Applique - Poor Fit
- Deck Lid Remote Release - Does Not Open Trunk
- Door/Door Trim Panel - Water Leaks To Interior
- Door Glass - Inoperable
- Wipers/Washers - Wipers Smear or Streak Windshield
- Rear Cup Holder - Comes Out Of Console
- Power Steering Pump - Moaning Noise
- Speed Sensor - Intermittent Loss of Cruise Control
- Accumulator - Intermittent DTC's 36, 52, or 54 Set
- Seat Track - Adjuster Linkage Clips Broken
- Remote Keyless Entry - Inadequate/Intermittent Operation
- Cowl Screen - Whistle Noise
- Cowl Plenum - Water Leaks
- A/C Evaporator - Emits Odors
- Power Steering System - Noise in Cold Temperatures
- Alignment - Vehicle Drift/Lead At Highway Speeds
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 240796 - 05/24/96
- 23-20-99 - 06/25/99
- 211196 - 07/19/96
- 21-18-96 - 12/27/96
- EBL Indicator Bulb - Does Not Operate
- Outside Rearview Mirror Glass - Replacement
- Emergency Trunk Release - Parts Identification
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Airbag - ON/OFF Switches Availability
- Steering Gear - Steering Noise When Turning Right
- Steering Wheel/Column - Clunking/Rattling
- Electrical - Wire Splice Procedure Revision
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- A/T - Vehicle Shudder During Torque Converter Operation
- Recall - Shifter and Ignition/Park Interlock Cable
- A/T Pan Gasket - Reusable Design
- A/T - Intermittent MIL ON/DTC's Set/Shift Concerns
- TCM - Limp In Mode Tendency Reduction
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- OBDII - Readiness Code Retention
- PCM - Flash Programming Failure Recovery
- Head Gasket - Improved Design/Installation
- A/T - Fluid Usage
- A/T - Vehicle Shudder During TC Lock-up
- A/T - ATF Usage List
- Spark Plug - Intermittent Single Cylinder Misfire/MIL On
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- 091196 - 11/08/96
- Service Manual - Updates
- Service Manual - Update
- Brakes - Noise Explanation
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Recall 96V006000: Oil Gallery Plug Leaks Engine Oil
- Engine - Service Manual Revisions
- Steering - Power Steering Pump R and I Revisions
- Front Brakes - Grinding or Squeaking Noise
- A/C Compressor - Failure/Performance Concerns
- A/C , Heater - Odors/Defroster Will Not Clear Glass
- Steering Gear - Whistle/Hiss On Right Turns
- Recall - Timing Belt
- Engine - Timing Belt Frayed/Shredded/Broken
- Engine - Timing Belt Installation Procedure Revision
- Engine - Timing Belt/Tensioner Service Revisions
- Cylinder Head - Oil Galley Plug Leaks
- Aluminum Engine - Gasket Surface Preparation
- A/C System - Performance Complaints
- Recall 97V201000: Control Arm/Ball Joint Separation
- Tire and Wheel - Runout
- Steering Wheel/Steering Column - Clunking Or Rattle
- A/T - Shudders During Upshift With No DTC's Present
- Converter Clutch - Vehicle Shudder on Lock Up
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Fluid is Burned/Internal Damage
- A/T - Ratcheting Sound When Coming To Stop
- Gearshift Service - Mandatory Battery Disconnecting
- Engine Controls/Emissions - Manual Revisions
- Cam Position Sensor - Oil Seepage Diagnosis
- PCM - OBDII Readiness Code Retention
- MIL ON, Hex Code $3E, Sag/Hesitation/Rough Idle
- Windshield Wiper - Delay Intervals Erratic
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- Recall 96V075000: Brake Master Cylinder Leak
- Recall - Master Cylinder Primary Piston
- Recall - ABS Master Cyl. Piston/Hydraulic Control Unit
- PCM - MIL ON/DTC's Set/Driveability Concerns
- Recall - Reprogram (Flash) PCM
- Recall - Reprogram PCM
- Recall - Reprogram (flash) PCM
- PCM - Erroneous EGR System Codes Set
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine Controls - Flash Programming Failure Recovery
- Air Filter Element Seal - Torn
- A/T - Shudder on 1 - 2/2 - 3 Upshift
- A/T - MIL ON/DTC's Set
- A/C - EBL Indicator Bulb Does Not Light
- Radio Communication Equipment - Recommendations
- Interior - Seat Belt Cinch Bar Service
- Airbag/Clock Spring - Service
- Engine - Oil Filter Application Change
- Ignition System - Secondary Ignition Test Revision
- Headlamp - Improved Design
- Multi Layer Steel Head Gasket - Installation Procedures
- Brakes - Bendix ABX 4 ABS System Test Revisions
- Tie Rod End - Intermittent Popping Noise
- Black Plastic Body Components - Chalky Residue
- B Pillar Applique - Poor Fit
- Radio Transmitters - Installation
- Recall - Passenger Air Bag Safety
- Airbag - NHTSA Authorized Deactivation
- Security System - Test Procedure Revision
- Emissions/Engine Controls - Service Manual Revisions
- Auto Computers - Y2K Effects
- Generic Scan Tool - Reference Information
- Engine Controls - Crankshaft Timing Re-Learn Procedure
- Engine Controls/Fuel System - DTC's/Lean Test Revision
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Recall 97V095000: Secondary Hood Latch Spring Revised
- Deck Lid Remote Release - Does Not Open Trunk
- Door/Door Trim Panel - Water Leaks To Interior
- Door Glass - Inoperable
- Wipers/Washers - Wipers Smear or Streak Windshield
- Outside Rearview Mirror - Glass Replacement
- Rear Cup Holder - Comes Out Of Console
- Engine - Coolant Recommendations
- Power Steering Pump - Moaning Noise
- A/T - Intermittent 2nd Gear and Reverse Only After Start
- A/T - 41TE/42LE Interactive Cruise Control
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - 41TE (A604) Solenoid Body Electrical Check
- A/T - 41TE (A604), 42LE Overdrive Clutch Hub/Improved
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - CD Compatibility
- A/T - ATF+4 Fluid Usage/Applications
- Transmission Range Sensor - Production Change
- Speed Sensor - Intermittent Loss of Cruise Control
- Front Cam Seal Retainer - New Design
- Recall - Front Lower Control Arm Ball Joints
- Recall - Engine Oil Galley Plugs
- Engine - Oil Capacity Specification Revision
- Wiring - Revised Splicing Procedure
- Speed Control - Adaptive Strategy
- Recall - Hood Latch Spring
- Windows - Interior Film Build Up
- Recall 98V183000: Ignition-Park Interlock System Fault
- Recall 04V021000: Shift Interlock Failure
- Recall - A/T Shifter Ignition/Park Interlock Defect
- M/T - Output Bearing Service Procedure Revision
- Recall 96V074000: ABS Hydraulic Control Unit Corrosion
- Crankshaft/Camshaft - Timing Procedure
- Accumulator - Intermittent DTC's 36, 52, or 54 Set
- Emergency Trunk Release - Availability
- Seat Track - Adjuster Linkage Clips Broken
- Remote Keyless Entry - Inadequate/Intermittent Operation
- A/C Refrigerant/Oil - Capacity Revisions
- Cowl Screen - Whistle Noise
- Cowl Plenum - Water Leaks
- A/C Evaporator - Emits Odors
- Garage Door Opener - Rolling Code Information
- Power Steering System - Noise in Cold Temperatures
- Steering - Power Steering Fluid Usage
- Engine - High Driveability Index Fuels
- Alignment - Vehicle Drift/Lead At Highway Speeds
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- A/T Pan Gasket - Reusable Design/Installation
- A/T - ATF + 4 Fluid Usage
- A/T - Repair/Replacement Guidelines
- Restraints - Child Seat Tether Installation
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process