Campaign - Headlamp Replacement

SI B63 02 03
Lights

June 2003
Service Engineering

This Service Information bulletin supersedes S.I. B63 02 03 dated April 2003.

PERFORM THE PROCEDURE OUTLINED IN THIS SERVICE INFORMATION ON ALL AFFECTED VEHICLES THE NEXT TIME THEY ARE IN THE SHOP FOR MAINTENANCE OR REPAIRS AND PRIOR TO RETAIL DELIVERY.

[NEW] designates changes to this revision

SUBJECT
Service Action to Replace Headlamps

MODEL
E85 (Z4)

SITUATION
The headlamps may vibrate slightly when driving on uneven surfaces.

CAUSE
Headlamps components that were not to specification were used during headlamp manufacture.

AFFECTED VEHICLES
This Service Action involves E85 (Z4) vehicles, which were produced between 30 January 2003 and 6 February 2003.

In order to determine if a specific vehicle is affected by this Service Action, it will be necessary to utilize the "Service Menu" of the DCS (Dealer Communication System). Based on the response of the system, either proceed with the corrective action or take no further action.





The Chassis Number Ranges listed are only for informational purposes and are not to be considered as the only deciding factor.

CORRECTION
Replace both headlamps.

For repair instructions, refer to RA 63 12 001 (non xenon) or RA 63 12 010 (xenon)





PARTS INFORMATION

LABEL INSTRUCTIONS

This Service Action has been assigned code number 357. Afier the vehicle has been checked, and corrected if necessary, obtain a label (SD 92-205) and:

a. emboss your BMW dealer warranty number in the middle of the label (1);

b. punch out code number 357 printed on the label and,





c. affix the label to the B pillar as shown.

If the vehicle already has a label from a previous Service Action/Recall Campaign, affix the new label next to the old one. Do not affix one label on top of another one because a number from an underlying label could appear in the punched-out hole of the new label.





WARRANTY INFORMATION
Reimbursement for this Service Action will be by Campaign Entry.