Windshield Wiper Motor With Wiper Motor Control Module

Windshield Wiper Motor with Wiper Motor Control Module

Observe notes on contact corrosion. Refer to => [ Contact Corrosion ] Service Precautions.

- If the control module was replaced, select the Replace function for the respective control module in Guided Fault Finding or Guided Functions.

- Select the function or path






- Follow the instructions on the Vehicle Diagnosis Tester display.

- Remove the wiper motor. Vehicles through 05.08, refer to => [ Wiper Motor with Wiper Motor Control Module, through 05.2008 ] Wiper Motor With Wiper Motor Control Module, Through 05.2008, vehicles from 06.08, refer to => [ Windshield Wiper Motor with Wiper Motor Control Module, from 06.2008 ] Windshield Wiper Motor With Wiper Motor Control Module, From 06.2008.

- Pry the drive rod - arrow - off the wiper motor crank using the pry lever (80-200).






- Remove nut - 1 -.






- Remove the crank - 2 - from the wiper motor.

- Remove wiper motor from wiper frame - arrows -.

- Bolt wiper motor without crank onto wiper frame - arrows -.






- Connect electrical connector.

- Switch on ignition.

- Perform next program step in Guided Functions.

• The Replace function in Guided Functions switches the wiper motor alternating park position off. The wiper motor then runs always to the lower park position which is the one for adjustment.

- Activate one-touch wiping and let wiper motor run in end position.

- Switch off ignition and remove ignition key.

- Align crank - 2 - toward wiper frame.






• Dimension - a - = 3 0.2 mm.

- Keep crank in position and hand-tighten nut - 1 - in order to maintain this position.

- Then, counterhold the crank in position using an open-end wrench and tighten nut.

- Switch on ignition.

- Activate one-touch wiping and let wiper motor run in end position.

- Check if dimension - a - is reached; align again if necessary.

- Switch off ignition and remove ignition key.

- Install the wiper motor. Vehicles through 05.08, refer to => [ Wiper Motor with Wiper Motor Control Module, through 05.2008 ] Wiper Motor With Wiper Motor Control Module, Through 05.2008, vehicles from 06.08, refer to => [ Windshield Wiper Motor with Wiper Motor Control Module, from 06.2008 ] Windshield Wiper Motor With Wiper Motor Control Module, From 06.2008.

Tightening Specifications