FREE REPAIR MANUALS & LABOR GUIDES 1982-2013 Vehicles
Courtesy of Operation CHARM: Car repair manuals for everyone.

Valvetrain Overview






Valvetrain Overview

Risk of damaging valves and piston heads after working on valvetrain.

The motor must not be started for about 30 minutes after installing camshafts because the hydraulic equalization elements must seat themselves.

To ensure valves do not strike pistons when starting, carefully rotate engine at least 2 full revolutions.

The illustration shows the cylinder bank 2 cylinder head (left).






1 Valve

Do not reface, only lapping is permitted

Mark the installed position for installation later

Checking, refer to => [ Valves, Checking ] Testing and Inspection

For the correct valve dimensions, refer to => [ Valve Dimensions ] Specifications

2 Cylinder Head

Valve guides, checking, refer to => [ Valve Guides, Checking ] Testing and Inspection

The valve seat may not be reworked due to a close tolerances.

3 Valve Stem Seal

Replace, refer to => [ Valve Stem Seals, Cylinder Head Installed ] Valve Stem Seals, Cylinder Head Installed, => [ Valve Stem Seals with Cylinder Head Removed ] Valve Stem Seals With Cylinder Head Removed

4 Valve Spring

5 Valve Spring Plate

6 Valve Retainers

7 Camshaft Seal

Removing and installing, refer to => [ Camshaft Seal ] Service and Repair.

8 Bolt

9 Nut

10 Guide Frame

With integrated camshaft bearings

Removing and installing, refer to => [ Left Cylinder Head Camshaft ] Left Cylinder Head Camshaft, => [ Right Cylinder Head Camshaft ] Right Cylinder Head Camshaft

11 Intake Camshaft

Removing and installing, refer to => [ Left Cylinder Head Camshaft ] Left Cylinder Head Camshaft, => [ Right Cylinder Head Camshaft ] Right Cylinder Head Camshaft

Measuring axial play, refer to => [ Camshaft, Measuring Axial Play ] Camshaft, Measuring Axial Play

Radial clearance, measuring, refer to => [ Camshaft, Measuring Radial Play ] Camshaft, Measuring Radial Play

Maximum run out: 0.01 mm

12 Exhaust Camshaft

Removing and installing, refer to => [ Left Cylinder Head Camshaft ] Left Cylinder Head Camshaft, => [ Right Cylinder Head Camshaft ] Right Cylinder Head Camshaft

Measuring axial play, refer to => [ Camshaft, Measuring Axial Play ] Camshaft, Measuring Axial Play

Radial clearance, measuring, refer to => [ Camshaft, Measuring Radial Play ] Camshaft, Measuring Radial Play

Maximum run out: 0.01 mm

13 Roller Rocker Lever

Removing and installing, refer to => [ Left Cylinder Head Camshaft ] Left Cylinder Head Camshaft, => [ Right Cylinder Head Camshaft ] Right Cylinder Head Camshaft

Mark the installed position for installation later

Check roller for easy movement

Lubricate the running surfaces before installing

14 Hydraulic Adjusting Elements

Mark the installed position for installation later

Checking, refer to => [ Hydraulic Adjusting Elements, Checking ] Testing and Inspection

Lubricate the running surfaces before installing

15 Pressure Relief Valve 1.0 Bar

25 Nm

For the lubricating points in the cylinder head

Left Cylinder Head Guide Frame, Tightening Specifications and Sequence





- Tighten the bolts and nuts in 2 steps in the sequence shown:






Right Cylinder Head Guide Frame, Tightening Specifications and Sequence





- Tighten the bolts and nuts in 2 steps in the sequence shown: